lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Yamaha
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles



Post New Thread  Reply
 
Thread Tools Display Modes
Old 07-16-2013, 07:49 PM   #1
mastercylinder63
Not Yet Wild
Club Car
 
Join Date: Oct 2010
Location: Long Island,NY
Posts: 32
Default G2 Gas starvation

I picked up a G2 that wasn't running too well. I gave it a tune-up, pulled apart the carb and cleaned the jet. I changed the tank filter and filled it up with fresh gas. I also put another in-line filter between the carb and the fuel pump. When I started it up and it would then stall within 5 seconds. I took the carb hose off the fuel pump and there was very little fuel pressure. Hardly any pressure to even push the fuel up to the end of the hose. So next, I changed the fuel pump. It pumps strong at low throttle, but when I nail it, the gas dribbles out of the fuel pump and starves the carb for fuel. The secondary fuel filter that I installed doesn't fill up like it should.
So I checked the engine compression and it's very strong. A few of the plastic pressure hoses coming off the engine going to the the fuel pump were very brittle. So I replaced them with rubber fuel line. Would this make a difference in fuel starvation???
mastercylinder63 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 07-27-2013, 02:44 PM   #2
Northern Boy
Not Yet Wild
 
Northern Boy's Avatar
Yamaha
 
Join Date: Jul 2012
Location: Cold Country, Mn
Posts: 35
Default

Check the air box to make sure it's sealed properly. I've heard that a slight leak will play havoc with the air/fuel mixture
Northern Boy is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Yamaha


Thread Tools
Display Modes


Similar Threads
Thread Forum
Oil Starvation on lifted 99 EZ Go? Gas EZGO


All times are GMT -5. The time now is 07:51 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2021, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. 2006-2017 Buggiesgonewild.com. All rights reserved.