lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car
Gas Club Car Gas DS, and Precedent golf cars

Post New Thread  Reply
Thread Tools Display Modes
Old 08-24-2011, 07:06 AM   #1
Getting Wild
Join Date: May 2009
Posts: 113
Default kf 82 weak spark

I am troubleshooting a friends cart that I think is a 91. I think. It does have the old kf82 engine like my '86. Do all these NOT have the igniter or a rev limiter? This thing has a very weak spark and will not fire at all. Just turns over. I tested the coil wires from the engine. Have not seen where the rev limiters and igniters are placed "if" they were added to the old engines. Only a 3 wire plug coming out of the block. Pulser was fine but exciting reads low. I believe the book says a reading from 350 to 360, not sure without having it on me. But I am getting 328. Which i would imagine to be the issue. And can anyone tell me where to find one. They were discontinued according to a few places I have called.
mortimer is offline   Reply With Quote
Alt Today

Golf car forum Sponsored Links

This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
Old 08-24-2011, 07:44 AM   #2
The Last Moja Morani
shadowman's Avatar
Club Car
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: kf 82 weak spark

no ignitor but if it has a limitor it should be mounted right on top of the coil.......chances are theres just the coil and the exitor coil and since theres no real way to bench test them if the connector is good and clean where the 2 plug together i would start with the coil only because its much easier to get to and a bit cheaper..............................
shadowman is offline   Reply With Quote
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car

Thread Tools
Display Modes

Similar Threads
Thread Forum
weak spark Gas EZGO
very weak spark Gas Club Car
99 ez go weak spark Gas EZGO
weak spark. What causes this Gas EZGO
Weak Spark Gas EZGO

All times are GMT -5. The time now is 06:24 AM.

Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2021, vBulletin Solutions, Inc.
This Website and forum is the property of No material may be taken or duplicated in part or full without prior written consent of the owners of 2006-2017 All rights reserved.