|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
10-24-2019, 07:44 PM | #11 |
Gone Wild
Join Date: Mar 2014
Location: NE Indiana & SW Florida
Posts: 3,238
|
Re: 2014 RXV Problem - State Of Charge Meter Drops Immediately
You could have one bad cell in that pack. Get a DVM and start checking each batteries while driving under load to see if one batteries drops very low.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
10-24-2019, 08:00 PM | #12 |
Resident Curmudgeon
Join Date: Oct 2011
Posts: 1,279
|
Re: 2014 RXV Problem - State Of Charge Meter Drops Immediately
Almost a guarantee the back battery is the bad one. Not sure why it's that one all the time that goes bad first or corrodes first.
|
10-24-2019, 08:06 PM | #13 |
Not Yet Wild
Join Date: May 2019
Location: GA
Posts: 11
|
Re: 2014 RXV Problem - State Of Charge Meter Drops Immediately
I'll give that a try tomorrow and will give an update. Thanks!
|
10-24-2019, 08:17 PM | #14 |
Resident Curmudgeon
Join Date: Oct 2011
Posts: 1,279
|
Re: 2014 RXV Problem - State Of Charge Meter Drops Immediately
Before doing any testing or working with the electronics be sure you put the car in TOW.
|
10-25-2019, 03:34 PM | #15 |
Not Yet Wild
Join Date: May 2019
Location: GA
Posts: 11
|
Re: 2014 RXV Problem - State Of Charge Meter Drops Immediately
Raining Here this afternoon and probably wont get a chance to run the Cart out this evening and see what's up after charging. Question..? - What voltage should the entire pack be at after a full charge, and what should it be running at with load?
Also, side note. I have a battery load tester being delivered tomorrow to check them all out. Thanks! |
10-25-2019, 03:48 PM | #16 |
Gone Wild
Join Date: May 2019
Location: Georgia
Posts: 389
|
Re: 2014 RXV Problem - State Of Charge Meter Drops Immediately
On the RXV, Battery number 4 (the Back one) seam to get neglected on a lot of carts we see. Low or no water, heavy corrosion, rotted cables. I have yet to see a 5 year old 12vdc battery inside a RXV, they just dont last
|
10-25-2019, 05:13 PM | #17 |
Gone Insane
Join Date: Oct 2015
Location: TN/NC/GA Tri-state area
Posts: 3,952
|
Re: 2014 RXV Problem - State Of Charge Meter Drops Immediately
Fast voltage drop during use, and fast voltage recovery after use, are both signs of sulphation. Typical cause is chronic undercharge due to not plugging it in quickly after use or wrong charger profile for the battery type/brand. Sulphation can be reversed, but it is not cheap or easy. The best cure is to take proper care of your batteries.
|
10-25-2019, 07:21 PM | #18 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: 2014 RXV Problem - State Of Charge Meter Drops Immediately
With as many "back battery" failures as I have seen on 4x 12v RXVs, I have to wonder if living so close to the heat of the motor might have something to do with it.
|
10-25-2019, 08:13 PM | #19 |
Resident Curmudgeon
Join Date: Oct 2011
Posts: 1,279
|
Re: 2014 RXV Problem - State Of Charge Meter Drops Immediately
I don't remember the motor getting nearly as hot as the DC cars do. But you can all but guarantee the positive cable from it always corrodes. never the negative oddly enough.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
2013 RXV State of charge drops to zero very quickly after reaching the 3/4 mark | Electric EZGO | |||
Curtis 803 State of charge meter/hour meter install | Electric Club Car | |||
OEM State of Charge Meter | Electric EZGO | |||
Help with LED state of charge meter | Electric EZGO | |||
State of Charge Meter...Which One? | Electric EZGO |