03-20-2011, 11:13 AM | #1 |
Not Yet Wild
Join Date: Mar 2011
Posts: 4
|
loose wire
I have a 1986 gas ezgo that i just got. I had to rebuild the motor on it. Got it all put back together and noticed i have a loose wire and i am not sure were it goes. Its a green wire that looks like its coming from the regulater and its hanging loose by the starter. Does any one have any idea where it goes or any pics.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
03-20-2011, 04:49 PM | #2 |
Gone Wild
Join Date: Feb 2011
Location: california
Posts: 151
|
Re: loose wire
Green wire goes to starter DF.
|
03-20-2011, 08:22 PM | #3 |
Not Yet Wild
Join Date: Mar 2011
Posts: 4
|
Re: loose wire
Hey thank you for your reply. I am not real familiar with these starter though and i am not sure what you mean by the DF. I was looking at the starter and there ia 4 red cables. Two on the end which someone has marked with a marker one has a L and the other has a R. Then there is two on the side that are stamped and one says F1 and the other says F2.
|
03-20-2011, 10:00 PM | #4 |
Gone Wild
Join Date: Jan 2011
Location: Nebraska
Posts: 665
|
Re: loose wire
Not sure if this will help you since it's not the same year. But scroll to the bottom for a 89 wiring diagram. It shows a green wire going to the starter. Hope this helps.
http://www.buggiesgonewild.com/ezgo-...iagram-id.html |
03-21-2011, 06:21 AM | #5 |
Respect the Cart
Join Date: May 2010
Location: Rocky Mount, Virginia
Posts: 2,190
|
Re: loose wire
VictorJohn is correct, the little DF terminal is underneath on the starter/generator. It may be easier to remove the unit to see where the wire goes. Remember that when you reconnect it you should use a thin wrench under the wire to ensure that the stud does not turn which will rip the wire off the inside of the generator and make you cry tears of bitter rage.
The green wire controls the battery charging rate, with it disconnected you will not be charging your battery, if it grounds out the charging voltage will rise to 18 volts and boil your battery dry. It would be good to hook it back up. Dave Last edited by Dave Box; 03-21-2011 at 06:21 AM.. Reason: sp |
03-21-2011, 08:12 AM | #6 |
Not Yet Wild
Join Date: Mar 2011
Posts: 4
|
Re: loose wire
Thanks everyone for all your replies. I got it hooked back up.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
How to wire a three wire Reducer | Electric EZGO | |||
2001 ds series - put lift on, now clicks and doesn't go?? Green motor wire loose? | Electric Club Car | |||
1993 gas ezgo loose wire on motor | Gas EZGO | |||
loose steering? | Electric EZGO | |||
Loose Ignition wire. Where does it go? | Electric EZGO |