|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
05-11-2018, 05:21 PM | #1 |
Not Yet Wild
Join Date: Nov 2016
Posts: 23
|
Differential chatter- cart barely moves
2004 TXT 36v, lifted 22 in tires
When the accelerator is pressed slightly, I can get a little movement. More pressure, and the rear starts to chatter. I figured stripped hub. I replaced both of them, along with some other stuff while it was torn down. Remounted everything, and have the same issue. Pulled the end cap off of the motor, and the motor isn’t turning. I read about low voltage can cause this symptom, low and behold, have one battery @ 4.2 after resting from charge. I know the bad battery is an issue, but is there something else in the diff that might cause this? I did hubs, brakes, motor bearing, spring/brush plate. After all of this, nothing changed. Any thoughts are greatly appreciated! |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
05-11-2018, 10:38 PM | #2 |
Gone Wild
Join Date: Feb 2017
Location: Richmond, TX
Posts: 1,026
|
Re: Differential chatter- cart barely moves
That battery is probably your only issue except 36 volt and 22 inch tires.
Convert it to 48V and be happy. Then you can do controller and motor as required. |
05-12-2018, 06:13 AM | #3 |
Not Yet Wild
Join Date: Nov 2016
Posts: 23
|
Re: Differential chatter- cart barely moves
I agree with you on the upgrades, but I’m just fixing this one for a friend. Have another stock TXT that I’m going to pull one battery, swap it, and see what happens.
Thanks for the response! |
|
|
Similar Threads | ||||
Thread | Forum | |||
97 36 volt DS resistor cart barely moves | Electric Club Car | |||
97 36 volt resistor cart barely moves | Electric EZGO | |||
gas cart starts but barely moves | Gas EZGO | |||
My motor runs, but my cart barely moves. | Electric EZGO | |||
Cart barely moves and grinding in rear end | Electric EZGO |