|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
03-14-2016, 01:19 PM | #1 |
Not Yet Wild
Join Date: Jun 2015
Location: South Carolina
Posts: 9
|
battery light and charging
I have a club car 2004 precedent. I just installed a alltrax xct 400. Had to do a little wire cutting and replacing. I have it all back together and running good. Very happy. SocttyB. Problem is now after my wiring job the battery light will blink, as if batteries are bad. I charged overnight an the charger never cut off or got below 10 volts charging. Sounded as if batteries were cooking. Batteries showed 52 volts after I unplugged the charger and let the batteries cool. Any suggestions.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
03-14-2016, 01:27 PM | #2 |
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: battery light and charging
Follow the "red" wire from the back of the charger receptacle and make sure it is connected to the pack positive battery post.
|
03-14-2016, 01:40 PM | #3 |
Gone Wild
Join Date: Feb 2011
Location: Chattanooga TN
Posts: 2,105
|
Re: battery light and charging
Since you were working with the controller I'd double check the neg wiring also.
|
03-14-2016, 01:51 PM | #4 |
Not Yet Wild
Join Date: Jun 2015
Location: South Carolina
Posts: 9
|
Re: battery light and charging
does it matter which way the neg goes through the obc, or does it even have to go through it?
|
03-14-2016, 01:56 PM | #5 |
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: battery light and charging
It does have to go through the OBC, but I cannot think of any other place You could have plugged that negative cable that would cause this problem.
|
03-14-2016, 07:00 PM | #6 |
Gone Wild
Join Date: Feb 2011
Location: Chattanooga TN
Posts: 2,105
|
Re: battery light and charging
Look in the very center of the picture I've attached. You will see some 10ga black wires circled in yellow connected together. When working on the controller it is very easy for these wires to come loose. These are for the charging circuit.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
battery charging light | Electric Club Car | |||
orange battery light fluttering when charging? | Electric Club Car | |||
Battery light comes on after charging | Electric Club Car | |||
Club car 48v charging issue and battery light | Electric Club Car | |||
Amber Battery Light Comes on After Charging | Electric Club Car |