|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
04-20-2008, 10:13 PM | #1 |
Not Yet Wild
Join Date: Apr 2008
Posts: 12
|
36 volt elecric club car charger
have used 36 volt elecric club car ran great last year. went to drive today no power no lights no horn. plugged in charger nothing happened .Had power outage over winter with temporary low voltage while nyseg was reparing power leg. . tested batteries a few were 4.5 volts plus cells appeared dry . added water hook up 12 volt deep cycle charger to each pair of 6 volt batteries. if this doesnt work can i try 3 12 volt deep cycle batteries to test system. should charger work with 3 12 volt batteries. Can i hook up 36 volt solar panel system?I f nothing works what should i try next. thanks
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-21-2008, 06:40 AM | #2 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,417
|
Re: 36 volt elecric club car charger
WELCOME !!!
Well, sounds like you are on the right path. Leaving batts in that cond. for extended times will kill them... 3/12s can test system. Check all connections for corrosion...Havent heard of anyone with a successful 36v solar system. Let us know if you find one !!! |
04-21-2008, 01:11 PM | #3 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: 36 volt elecric club car charger
you can charge 2 at a time with a 12 volt charger, do each set about an hour and than try your charger if nothing is wrong charger will come on........1st fill them with distilled water only than clean and tighten all cable terminal ends.......................................
|
04-22-2008, 09:36 PM | #4 |
Not Yet Wild
Join Date: Apr 2008
Posts: 12
|
Re: 36 volt elecric club car charger
Charged pairs of 6 volt batteries with 12 volt charger. 36 volt charger came back on . charged at 16 amps for over 3 hours became warm . I disconnected charger. one battery still test under 6 volts . Is charger supposed to draw 16 amps over prolong period ? Can i replace just the low charge battery ? Thanks
|
04-22-2008, 09:55 PM | #5 |
nimda
Join Date: Jun 2007
Posts: 13,022
|
Re: 36 volt elecric club car charger
It depends on how low the batteries are....so yea. A fully dead pack will take about 10 hours or so to fully charge. Its not reccommended (but you can) to change just 1 battery because the pack will be out of balance....but if one golf cart battery is dead the pack is out of balance anyways so what do you have to loose.
|
04-22-2008, 10:02 PM | #6 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,417
|
Re: 36 volt elecric club car charger
If I may suggest...Since the pack is older try finding a used 6v. Check the rest of the pack before. Make sure all are within 2/10s of a volt of each other or imbalance persists. U can post the readings here for more anaylsis input?
But normal for the charger to run too strong too long with 1 bad battery. So here is where the danger comes in cause the charger can cook (overcharge) the gd ones trying to salvage the bad one... |
04-23-2008, 11:15 AM | #7 |
Not Yet Wild
Join Date: Apr 2008
Posts: 12
|
Re: 36 volt elecric club car charger
any suggestion as where to purchase trogan batteries?
|
04-23-2008, 11:37 AM | #8 |
nimda
Join Date: Jun 2007
Posts: 13,022
|
Re: 36 volt elecric club car charger
Most golf cart dealers carry them. Don't order them online...the shipping cost will be huge and they will not be filled with electrolyte. Sams carries other brands of golf cart batteries.
|
05-06-2008, 08:19 PM | #9 |
Not Yet Wild
Join Date: Feb 2008
Posts: 20
|
Re: 36 volt elecric club car charger
why would you want to just replace 1 battery with a new one, that new one will only be as good as the rest, get a good used battery and put in it, plus it will save you some money.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
48 Volt Charger | Golf Carts and Parts | |||
48 volt charger NEW NEW NEW | Golf Carts and Parts | |||
For sale Lestronics 36 volt charger | Golf Carts and Parts | |||
36 Volt...35Amp Charger??? | Electric Club Car | |||
24 volt battery charger | Autos/Side x Sides/ATVs/4x4's |