|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
08-30-2021, 12:53 PM | #1 |
Not Yet Wild
Join Date: Nov 2019
Posts: 17
|
FE290 Fuel Filters almost empty
I have a 1998 Club Car with a FE290 Kawasaki motor. The cart will run fine for a short period (3/4 mile) and then die like it is running out of gas. Checked the fuel lines and both the filter near the tank and the one near the carb have very little fuel in them. I changed out the fuel filters and manually filled the one near the the tank with fuel and the cart started and seems to run fine. (20 minutes under a load) but when I check the filters both were just about empty. Any ideas, is this normal? I did blow air back through the pickup tube and also check the fuel line going to the Carb by putting in the line into a bottle and turning the motor over. Not sure how much should be coming out of the pump, seem like a very slow stream. Any idea how much fuel pressure I should be seeing coming out of the pump?
Thanks |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-30-2021, 02:33 PM | #2 |
Gone Wild
Join Date: Jun 2011
Location: Northern Indiana
Posts: 2,823
|
Re: FE290 Fuel Filters almost empty
Those fuel pumps will run almost no pressure. Just about the same as gravity feed, probably less than1 lb of pressure at best. Open flow it will be just a small trickle. Keep in mind the pump runs on a pressure / vacuum pulse so the stream will pulse - not steady like an electric pump. You will never eliminate the air from the fuel filters If there is enough gas to fill as high as the outlet tube of the filter, it's enough.
Last edited by meimk; 08-30-2021 at 02:34 PM.. Reason: typo |
08-30-2021, 02:44 PM | #3 |
Not Yet Wild
Join Date: Nov 2019
Posts: 17
|
Re: FE290 Fuel Filters almost empty
Thanks for the reply, so I guess if the cart is running ok don't worry about.
|
08-30-2021, 06:56 PM | #4 |
Bonafide Nincompoop
Join Date: Dec 2015
Location: Charlottesburg Va
Posts: 8,987
|
Re: FE290 Fuel Filters almost empty
If filters are totally full that's usually when I replace them, because that's often an indicator that they're blocked or have water in them. These can have next to no fuel visible at all in the filters and still run fine.
As long as the pump is squirting some fuel, it's usually more than enough. |
09-06-2021, 08:48 AM | #5 |
Not Yet Wild
Join Date: Nov 2019
Posts: 17
|
Re: FE290 Fuel Filters almost empty
Really need some help, I am totally stumped. Put a new fuel pump and filters and spark plug. Drove about 5 miles and and it ran great then about 1/2 mile from home it acted like it was running out of gas and quit. After about 1 minute it started back up went about 1/4 mile and did it again. Any idea what can be causing it? Going to put a new vacuum line on but I don't believe that is the problem. This is driving be nuts!
|
09-06-2021, 10:57 AM | #6 |
Not Yet Wild
Join Date: Aug 2021
Posts: 21
|
Re: FE290 Fuel Filters almost empty
Sounds like the same issue I’m having. Ive swapped out all fuel lines, fuel pump and went right through the carb to make sure the float is working fine. Checked all vent/breather lines. Good compression and pulse line. For such a low tech system it sure has its issues.
|
09-06-2021, 02:19 PM | #7 |
Not Yet Wild
Join Date: Nov 2019
Posts: 17
|
Re: FE290 Fuel Filters almost empty
If you figure it out please post the fix, thanks
|
09-06-2021, 03:06 PM | #8 |
Gone Wild
Join Date: Jun 2011
Location: Northern Indiana
Posts: 2,823
|
Re: FE290 Fuel Filters almost empty
Check for spark. Majority of "runs good till it gets hot" issues are a loss of spark.
|
09-06-2021, 03:10 PM | #9 |
Not Yet Wild
Join Date: Nov 2019
Posts: 17
|
Re: FE290 Fuel Filters almost empty
spark is strong. The cart act like it runs out of gas and quits, wait less then a minute and it will start running fine again but will quit more often the more you run it. Sometimes just punching the choke a few time will keep it running. At a loss.
|
09-06-2021, 05:41 PM | #10 |
Not Yet Wild
Join Date: Aug 2021
Posts: 21
|
Re: FE290 Fuel Filters almost empty
Mine died again today, no fuel in the fuel filter again. I will swap out the coil for a new one (maybe on Thursday if not on the weekend)and see if that has anything to do with it. Ill keep you posted.
|
Tags |
1998 fe290 club car |
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
G1 empty fuel filter=bad fuel pump or tank vaccuum? | Gas Yamaha | |||
one or two fuel filters | Gas Club Car | |||
Whiteish cloudy fuel in the fuel filters? | Gas Club Car | |||
fuel filter empty | Gas EZGO | |||
Air Filters, Fuel Filters, Spark Plugs. whole lot for sale | Golf Carts and Parts |