|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
03-30-2015, 03:42 PM | #11 |
STEALTH 4X4
Join Date: Sep 2011
Location: GA
Posts: 2,125
|
Re: 05 rebuild problem
Ok so do what CCfanatic said and jump the 2 wire plug on the MCOR with a paper clip, with the rear end jacked up
"2. I let batteries get down a little on purpose just to see if that's the problem" - batteries should never be ran below 50% |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
03-30-2015, 03:47 PM | #12 |
STEALTH 4X4
Join Date: Sep 2011
Location: GA
Posts: 2,125
|
Re: 05 rebuild problem
I suspect your pedal has worn and can't give the accelerator pivot barll range of motion to turn the mcor.
Use the file that gives you the highest throttle postion. Remove the mcor from the cart and actuate it by hand (with the rear jacked up of course) to see if you get to 100%. If so, replace the go pedal. The aluminum gets worn over time and will "divot" out, causing the MCOR not to get the full turn from the pivot bar. |
03-30-2015, 04:00 PM | #13 |
Getting Wild
Join Date: Mar 2015
Location: Southwest louisiana
Posts: 109
|
Re: 05 rebuild problem
Files
|
03-30-2015, 04:11 PM | #14 | |
Getting Wild
Join Date: Mar 2015
Location: Southwest louisiana
Posts: 109
|
Re: 05 rebuild problem
Quote:
2. probably need new batteries |
|
03-30-2015, 04:34 PM | #15 |
Getting Wild
Join Date: Mar 2015
Location: Southwest louisiana
Posts: 109
|
Re: 05 rebuild problem
Never shut off yet with wheels off ground
This is with the throttle set on club car!! |
03-30-2015, 04:34 PM | #16 |
Getting Wild
Join Date: Mar 2015
Location: Southwest louisiana
Posts: 109
|
Re: 05 rebuild problem
Setting on ezgo
|
03-30-2015, 04:36 PM | #17 |
Getting Wild
Join Date: Mar 2015
Location: Southwest louisiana
Posts: 109
|
Re: 05 rebuild problem
mcor good.....batteries bad???
|
03-30-2015, 05:19 PM | #18 |
STEALTH 4X4
Join Date: Sep 2011
Location: GA
Posts: 2,125
|
Re: 05 rebuild problem
Is that from you doing the paperclip test?
|
03-30-2015, 05:24 PM | #19 |
Getting Wild
Join Date: Mar 2015
Location: Southwest louisiana
Posts: 109
|
Re: 05 rebuild problem
|
03-30-2015, 08:48 PM | #20 |
Getting Wild
Join Date: Mar 2015
Location: Southwest louisiana
Posts: 109
|
Re: 05 rebuild problem
Bump
|
|
|
Similar Threads | ||||
Thread | Forum | |||
cart rebuild charger problem!!! | Electric Club Car | |||
G9 motor rebuild problem | Gas Yamaha | |||
fresh rebuild problem | Gas EZGO | |||
motor rebuild problem | Gas EZGO | |||
Problem with rebuild | Gas Yamaha |