|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
04-05-2016, 06:46 AM | #1 |
Getting Wild
Join Date: Sep 2008
Posts: 99
|
at a lost with fuel system G1
1985 g1 if i squirt gas in carb runs for a second
hooked up gravity feed gas and runs great fuel is pumping out of stock fuel line then hooked back up to stock fuel system ran for 10 minutes and died back on gravity now and runs so my qustion is fuel pump good condition and clean carb cleaned what next or can it be the carb still? |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-05-2016, 06:51 AM | #2 |
Gone Wild
Join Date: Oct 2010
Location: Central New York
Posts: 812
|
Re: at a lost with fuel system G1
Does the G-1 have a fuel filter inside the tank as the G-9 does? I have had that filter go bad on three of my carts!! On the G-9 its near the bottom of the tank. If you follow the supply line from the fuel pump you cant miss it. Its a big screw off cap and the filter is in the cap.
|
04-05-2016, 07:07 AM | #3 |
Getting Wild
Join Date: Sep 2008
Posts: 99
|
Re: at a lost with fuel system G1
filter on outside of tank
|
04-05-2016, 10:31 AM | #4 |
Gone Wild
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,669
|
Re: at a lost with fuel system G1
Pull rubber grommet out on top of the tank and make sure pickup line isnt plugged or broken off
|
04-05-2016, 11:02 AM | #5 |
Gone Wild
Join Date: Oct 2010
Location: Pittsburgh Pa
Posts: 1,551
|
Re: at a lost with fuel system G1
Check the plastic piece inside the rubber grommet on top of tank. Very common for those to crank.
|
04-05-2016, 02:11 PM | #6 |
Gone Wild
Join Date: Feb 2007
Location: Southwest Georgia
Posts: 1,469
|
Re: at a lost with fuel system G1
Could be crankshaft seal leaking, not pulsing enough for fuel pump
|
04-05-2016, 06:48 PM | #7 |
Sometime's............
Join Date: Oct 2007
Location: Tacoma Washington
Posts: 11,875
|
Re: at a lost with fuel system G1
The rubber hose connection from the fuel filter to the hard line can be cracked/leaking that could cause that. The small crankcase brass fitting and hose could be damaged causing the fuel pump not to have full "pulsar" from the crankcase pressure and lose it's prime. Just throwing this out there. All good suggestions
|
04-06-2016, 12:28 AM | #8 |
Gone Wild
Join Date: Nov 2011
Posts: 232
|
Re: at a lost with fuel system G1
also check the vent on the tank!
|
04-06-2016, 10:02 PM | #9 |
Getting Wild
Join Date: Sep 2008
Posts: 99
|
Re: at a lost with fuel system G1
Thank again to this gret forum
New filter ,vent cap taken out cleaned and running great today |
|
|
Similar Threads | ||||
Thread | Forum | |||
1988 ez go gas fuel system problem | Gas EZGO | |||
1990 marathon fuel system | Gas EZGO | |||
88 EZ GO gas golf cart fuel system! | Gas EZGO | |||
Fuel System ? | Gas Yamaha |