|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
04-13-2016, 05:19 PM | #11 |
Not Yet Wild
Join Date: Apr 2016
Location: Florida
Posts: 16
|
Re: Yamaha G9A Smoking terrible....HELP
Finally got engine apart and with caliper measures at top of cylinder at 2.873
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-15-2016, 09:05 PM | #12 |
Vegas modded 420
Join Date: Jun 2009
Location: West MI
Posts: 15,445
|
Re: Yamaha G9A Smoking terrible....HELP
I don't know the spec for it, but the oil rings as said blow first in most of these. They run fine and burn oil. Either you rebuilt it, or you put a clone engine in it. If it has not been rebuilt before you can usually ring it and hone the cylinder, it may burn a little oil after that. If its already been done you need to bore it for oversize piston then it will be like new. Should use one quart of 10-30, maybe 30w if you are in a hot area, one quart only, that is full oil check the stick and never fill it more than what that shows on level ground. When mine went it was more for a rebuilt at a dealer than my whole clone swap was, but that was a nice new bore rebuilt at a yami dealer it was walk in the door and swap bare engines and walk out (no labor included).
|
06-17-2016, 05:20 PM | #13 |
Not Yet Wild
Join Date: Apr 2016
Location: Florida
Posts: 16
|
Re: Yamaha G9A Smoking terrible....HELP
Finally got it rebuilt and did the complete rebuild bored .20 and all new bearings and valves. The issue I am having now is put a new carb and when I connect the air filter box it smokes like crazy but disconnect and no smoke. Probably sounds crazy but it is driving me crazy....any ideas
|
06-17-2016, 08:13 PM | #14 | |
Gone Wild
Join Date: Nov 2012
Location: Southeastern Pa.
Posts: 319
|
Re: Yamaha G9A Smoking terrible....HELP
Quote:
|
|
06-17-2016, 08:28 PM | #15 |
Not Yet Wild
Join Date: Apr 2016
Location: Florida
Posts: 16
|
Re: Yamaha G9A Smoking terrible....HELP
It seems to be a whitish grey smoke with air box off and if I put my hand over carb and restrict air flow it smokes remove hand and smoke stops
|
06-18-2016, 04:45 AM | #16 |
Crazy Ole Man
Join Date: Jan 2016
Location: Owego NY
Posts: 2,758
|
Re: Yamaha G9A Smoking terrible....HELP
When you rebuilt it -- did you replace the valve guide seals?
|
06-18-2016, 05:19 AM | #17 |
Not Yet Wild
Join Date: Apr 2016
Location: Florida
Posts: 16
|
Re: Yamaha G9A Smoking terrible....HELP
Yes had the head rebuilt with new valves and seal
|
06-18-2016, 05:22 AM | #18 |
Not Yet Wild
Join Date: Apr 2016
Location: Florida
Posts: 16
|
Re: Yamaha G9A Smoking terrible....HELP
Since rebuild it ran fine then I noticed the carb adapter was cracked but still ran ok but this began when I replaced the carb adapter. Since then I have purchased a new oem carb and that is where I am now
|
06-18-2016, 08:18 PM | #19 |
Gone Wild
Join Date: Nov 2012
Location: Southeastern Pa.
Posts: 319
|
Re: Yamaha G9A Smoking terrible....HELP
Sounds like, from your description, that the grey-white smoke is oil smoke. The black smoke is usually from an overly rich fuel condition. The problem I'm having is trying to figure out how attaching the airbox can cause the engine to burn oil. The only thing that I can think of is that there is a hose on the airbox that connects to the breather, and it might be sucking oil through that. If there is such a hose, try disconnecting it and see if the smoke goes away.
|
06-18-2016, 09:49 PM | #20 |
Not Yet Wild
Join Date: Apr 2016
Location: Florida
Posts: 16
|
Re: Yamaha G9A Smoking terrible....HELP
I have taken off the hose and no change. This all started when I replaced the carb mount adapter before that it didn't smoke at all since rebuild and the other carb adapter was cracked. My other thing I am going to check is to see if the exhaust is finally starting to burn off oil from before rebuild. Thanks and I will let you know what I find
|
|
|
Similar Threads | ||||
Thread | Forum | |||
yamaha g9 smoking | Gas Yamaha | |||
2001 Yamaha Smoking | Gas Yamaha | |||
03 yamaha smoking | Gas Yamaha | |||
96 yamaha gas smoking | Gas Yamaha | |||
smoking yamaha | Gas Yamaha |