|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
01-20-2013, 04:36 PM | #1 |
Gone Wild
Join Date: Nov 2012
Location: North Carolina
Posts: 161
|
Are these brushes worn out ???
I will be replacing but just wanted to know for future reference. I couldnt tell where the indicator marks should be. Just wanted to know if they are bad to the point the starter will barely turn or if im on a wild goose chase
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
01-20-2013, 04:59 PM | #2 |
Not Yet Wild
Join Date: Nov 2010
Location: PEI canada
Posts: 19
|
Re: Are these brushes worn out ???
No those appear to be fine. getting down there but that's not likely your problem
|
01-20-2013, 06:11 PM | #3 |
Gone Wild
Join Date: Dec 2012
Location: Warren Mi
Posts: 233
|
Re: Are these brushes worn out ???
Got good life left in um .. from what I see. Make sure the armature is clean and not clogged between the groves where the brushes run... that could be where your losing power to crank.
|
01-20-2013, 07:11 PM | #4 |
Not Yet Wild
Join Date: Dec 2012
Location: Port Aransas TX
Posts: 56
|
Re: Are these brushes worn out ???
Sometimes a good cleaning will do wonders. I take a popcicle stick and square one end with a utility knife then thin it down until it will go between the comutator segments, in the slots and clean the build up out. If they are ruff take a nonmetalic fine grit sand paper, I use a 600 grit at least and go arround the comutator until it shines up and slicks out. If you do that clean the slots last and blow everything out with air to remove all the crud. Check the bearings and make sure they are free. This usually works wonders unless something else is going on..............
|
|
|
Similar Threads | ||||
Thread | Forum | |||
g16 clutch(es) loud? and/or worn?? | Gas Yamaha | |||
Signs of worn motor brushes? | Electric Club Car | |||
Worn Clutch Cam and Slides | Gas EZGO | |||
Worn out drive clutch? | Gas Club Car | |||
Electrical Diagram for Gas G2/Worn brushes | Gas Yamaha |