10-10-2018, 12:42 PM | #1 |
Not Yet Wild
Join Date: Sep 2018
Location: Miami, FL
Posts: 23
|
Stuck motor
Ok so I’m once again looking for help I got the cart to roll after what appeared to be a locked up motor now can seem to get the motor off the transaxle any tutorials anyone know of that can assist me in getting this thing off.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
10-10-2018, 02:30 PM | #2 |
Just Gone
Join Date: Sep 2015
Location: North Carolina
Posts: 3,549
|
Re: Stuck motor
|
10-10-2018, 02:31 PM | #3 |
Bonafide Nincompoop
Join Date: Dec 2015
Location: Charlottesburg Va
Posts: 8,987
|
Re: Stuck motor
Remove the three 1/4 - 20 bolts from around the top and sides of the bell housing.
Remove one 5/16 - 18 bolt from the bottom facing toward passenger side. Motor should slide off. If it doesn't its due to rust in the splines on the input coupler. Try wiggling it up/down and pry some with a prybar or big screwdriver. If it doesn't move easily you'll have to take the two small screws out of the end of the motor to release the bearing holder, then pull the outer housing off of the armature to get better leverage to pull the armature off of the trans. |
05-21-2019, 03:41 PM | #4 |
Gone Wild
Join Date: May 2019
Location: Georgia
Posts: 389
|
Re: Stuck motor
The worst stuck motor i experienced was a cart that tried to go swimming, carts don't swim very well. I have replaced hundreds of motors, very seldom i have to pull off the motor case, this time i had to pull the rear end, place in a bench vise with the motor hanging down, several cans of pb blast , pin point heat, banging & praying & after several hours later it fell to the floor. Good luck
|
05-22-2019, 07:15 AM | #5 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: Stuck motor
|
|
|
Similar Threads | ||||
Thread | Forum | |||
stuck motor | Electric EZGO | |||
TXT motor getting stuck | Electric EZGO | |||
motor stuck | Electric Club Car | |||
stuck pds motor | Electric EZGO | |||
Stuck motor | Electric Club Car |