|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
05-03-2012, 03:15 PM | #1 |
Not Yet Wild
Join Date: May 2012
Location: Illinois
Posts: 6
|
E-Z-Go Dump Cart ID? & Cart leans/pulls left.
Hi everyone,
I bought a 3 wheeled E-Z-Go dump cart. It is my profile picture. I also uploaded some pictures to my profile album. The codes on the body tag are as follows: E-Z-GO TEXTRON Polaris E-Z-Go Division of Textron Inc. AUGUSTA GEORGIA SERIAL NO. 0805148 0800660 This is the only tag I could locate on the body. The year and model is unknown to me. I would like to know the year, make and model so I can order some parts and get this thing looking nice again. It has a gas 2 cylinder Onan engine. Does anyone know what horse power the engine rated at? The engine codes are as follows: B48M-GA01813450A & J793485630 Manual 3 forward speed/reverse transmission with Hi and low range. It appears to have a pto or other unknown attachment on the back side of the transmission. See picture for better idea. It's the one with the tape or something wrapped around the shaft. This is how I got it. What is this and what does it do? This thing ran like junk when purchased. It sat outside and had about 50/50 water and gas in the tank. I cleaned the carburetor, changed the oil & fuel filter, replaced the spark plugs and now it runs like a top! The only complaint I have is that it leans to the left. The driver/left side sits lower than the right. Any ideas? It leans a bit and I could live with this, but while driving it wants to pull pretty bad to the left. Any ideas? With haveing one wheel in front, i don't know what to look for. It had a manual dump bed, now has an electric hoist installed...sure beats a shovel! I need a few gauges. Fuel level, Amp gauge and hour meter first off. I need a headlight and how to get it out. The rubber is too tight to pull off and I can't get to the three nuts. How do I replace the headlight? I know this is a lot to ask of complete strangers, but I find there are still some pretty good folks out there. Thanks everyone. Clint. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
05-26-2012, 05:47 PM | #2 |
Not Yet Wild
Join Date: May 2012
Location: Illinois
Posts: 6
|
Re: E-Z-Go Dump Cart ID? & Cart leans/pulls left.
Hi again,
I see quite a few folks have viewed my post. I hope everyone likes the pictures. Does anyone have a clue what model this thing is so I can get some parts ordered? I have called EZ-Go and they said the numbers don't match any listing they have on records. Any help would be appreciated. Thanks, Clint |
05-26-2012, 06:28 PM | #3 |
Not Yet Wild
Join Date: May 2011
Location: Jacksonville, Fla
Posts: 35
|
Re: E-Z-Go Dump Cart ID? & Cart leans/pulls left.
Hey Clint, good luck, that thing looks bad ***.I would assume leaning to the left would mean something is worn out from haulin' around a big fat tub of lard for so long (no offense).
My first drastic plan of action (other than getting it running) would be to figure out how to get that thing on four wheels, big time, major modification required. I would be looking for a donor cart, hone up on your welding skills and dive in, some big time potential there... |
05-26-2012, 06:58 PM | #4 | |
Not Yet Wild
Join Date: May 2012
Location: Illinois
Posts: 6
|
Re: E-Z-Go Dump Cart ID? & Cart leans/pulls left.
Quote:
Joejax, As I said in the original post, It runs just fine now. It just leans a little and there is no way I'm going to modify it to four wheels. I am just looking for information of a possible year, make and model of the cart. Thanks, Clint |
|
05-26-2012, 07:21 PM | #5 |
Not Yet Wild
Join Date: May 2011
Location: Jacksonville, Fla
Posts: 35
|
Re: E-Z-Go Dump Cart ID? & Cart leans/pulls left.
Well, for some reason, they stopped making 3 wheel carts and 3 wheel ATVs, so...I don't know, just a thought.
You could have some kind of Frankenstein there, part EZGO, part Cushman, put together by an independent company, who knows. I guess you will be OK leaving it original, I'm not familiar with the 3 wheelers, suspension issues would be my guess. Good luck! |
05-26-2012, 07:25 PM | #6 |
Warthog cart
Join Date: Aug 2011
Posts: 502
|
Re: E-Z-Go Dump Cart ID? & Cart leans/pulls left.
Could be your wheel bearings are shot on one side of the front wheel, could be a brake dragging, maybe a low tire on the left?Lots of maybes.I'd get it up on blocks and check out that undercarriage.If you would though, straighten the front wheel and get a nice straight on look at the front end.I can't tell if it's leaning or if it's just the way the front end is turned.
|
05-27-2012, 12:57 AM | #7 |
Gone Wild
Join Date: Jan 2011
Location: Las Vegas, Nevada
Posts: 1,942
|
Re: E-Z-Go Dump Cart ID? & Cart leans/pulls left.
In the pics you posted you can tell that front wheel is jacked to the side pretty bad. It isn't exactly in the center any more it's more on the passenger side. I'd pull off the front cowl and check the frame and front forks for damage. That thing is really cool btw good luck with it and keep us posted.
|
05-27-2012, 09:45 AM | #8 |
Gone Wild
Join Date: Jun 2008
Location: Raytown, Missouri
Posts: 894
|
Re: E-Z-Go Dump Cart ID? & Cart leans/pulls left.
Hi Clint, their is some info here on 3 wheelers that might help, good luck you have a neat project their. Does the motor have onan performer on it?
http://www.bennettgolfcars.ca/ezgo_manuals.php Last edited by popatop; 05-27-2012 at 10:21 AM.. Reason: question |
05-31-2012, 02:07 AM | #9 |
Not Yet Wild
Join Date: May 2012
Location: Illinois
Posts: 6
|
Re: E-Z-Go Dump Cart ID? & Cart leans/pulls left.
Thanks Popatop! The website helped. I believe I have a 1988 (or so) EZ-Go GTX 1500 "Gasoline Powered Heavy Duty Truck." I'm pretty sure the model is correct, still unsure of the year.
Thanks again! |
05-31-2012, 06:20 PM | #10 |
Gone Wild
Join Date: May 2011
Location: Las Vegas NV
Posts: 330
|
Re: E-Z-Go Dump Cart ID? & Cart leans/pulls left.
I would replace the front with another 2 wheels. An old EZGO would be a good option. Then you have a 4 wheel cart.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
2001 utv dump cart | Gas Club Car | |||
Cart leans to one side | Gas EZGO | |||
cart leans | Electric EZGO | |||
cart leans | Electric Club Car | |||
Help My Cart Leans | Electric EZGO |