08-08-2012, 01:11 PM | #1 |
Not Yet Wild
Join Date: Apr 2011
Posts: 7
|
1991 ezgo 2 cycle
does anyone know what could be wrong with this cart i put new battery in 2 months ago i was riding around the other day it was running fine i went to take off again and it wouldnt do anything my lights were on and when i hit the gas they would cut off where should i start looking any help would be great thanks...
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-08-2012, 02:41 PM | #2 |
Gone Wild
Join Date: May 2011
Location: Michigan
Posts: 271
|
Re: 1991 ezgo 2 cycle
I am going through the same thing........
|
08-08-2012, 04:10 PM | #3 |
Not Yet Wild
Join Date: Apr 2011
Posts: 7
|
Re: 1991 ezgo 2 cycle
Yea it was running great then nothing i have not checked much on it yet but i was wondering if it was the starter generator??
|
08-08-2012, 04:29 PM | #4 |
I Refuse To Get Stuck!!!
Join Date: Jun 2010
Location: Hilton,NY
Posts: 5,427
|
Re: 1991 ezgo 2 cycle
Try a battery-voltage test first.If the Starter/Generator isn't working,the battery will be dead.If the battery is up,the next place to look is the battery-cables(Pos. and Neg.)One bad connection will shut down everything.Start with that,and also you can jack the cart up,set the rear-axle on stands,start the cart and recheck the voltage.It should increase at least 1-volt from what it read without it running(12-12.5v not running,13-14.5v running).Hope this helps.
|
08-08-2012, 05:07 PM | #5 |
Not Yet Wild
Join Date: Apr 2011
Posts: 7
|
Re: 1991 ezgo 2 cycle
Thanks alot i will check it out this weekend
|
08-12-2012, 07:32 PM | #6 |
Not Yet Wild
Join Date: Apr 2011
Posts: 7
|
Re: 1991 ezgo 2 cycle will not start
cart broke down couple days ago battery went dead so i charged it up this is a new battery so i think the starter generator is not charging . but after i charged it up now it will not start up. i can smell gas and i pulled the plug its firing checked fuse its good can anybody tell me what it could be? thanks for looking...
|
08-12-2012, 09:56 PM | #7 |
I Refuse To Get Stuck!!!
Join Date: Jun 2010
Location: Hilton,NY
Posts: 5,427
|
Re: 1991 ezgo 2 cycle
Was the plug soaked?The float may be stuck in the carb,now its' flooding.Try unhooking the fuel-line at the inlet to the pump,to prevent more fuel being pumped.Set the rear-axle on stands,Crank it over a bit,then give it a shot of starting-fluid.If it starts,then you know its' a fuel-problem.Start with cleaning the carb and re-setting the float-height.Set it level with the gasket-surface of the bowl-flange.Hope this helps.
|
08-13-2012, 07:52 AM | #8 |
Gone Wild
Join Date: May 2011
Location: Michigan
Posts: 271
|
Re: 1991 ezgo 2 cycle
qustion! if the starter geneator is bad. would this happen, when I turn the key to on,
then I hit the gas the main fuse pop's. please help. |
09-03-2012, 04:10 PM | #9 |
Gone Wild
Join Date: Jan 2012
Location: Kansas City, Mo
Posts: 544
|
Re: 1991 ezgo 2 cycle
Ams sounds like you have a direct short in the wiring? It might be in the Voltage Regulator. unplug or cut the green ground wire coming off the regulator and see if it will run.
|
09-03-2012, 06:31 PM | #10 |
Gone Wild
Join Date: May 2011
Location: Michigan
Posts: 271
|
Re: 1991 ezgo 2 cycle
Doc, that was not it. I am at a loss. do you have any pic's of your wiring.
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
EZGO Service Manual 1991-1993 4 Cycle Gas | Gas EZGO | |||
Ignition Coil 1991 EZGO Marathon 2 cycle | Gas EZGO | |||
Wanted: Starter/generator for a 1991 2 cycle ezgo | Golf Carts and Parts | |||
Ignitor 4 cycle Ezgo gas 1991 - Up | Golf Carts and Parts |