|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
02-23-2019, 08:00 AM | #1 |
Not Yet Wild
Join Date: Oct 2016
Posts: 73
|
05 precedent intermitently dies help please!!!!
Cart dies.solonoid failed.replaced and drove for a week then died again.jumped fwd rev switch and got it home and replaced switch and drove 4 more days then lost fwd but drove home in reverse.woke up got in and drove fine in fwd and rev.only happens after driving 20 min or so.good pack voltage and all batteries pass hydrometer test
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
02-23-2019, 06:12 PM | #2 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: 05 precedent intermitently dies help please!!!!
Either a short in a wire going to the switch (or sonic weld point), faulty switch, or controller is starting to go. Have to do some detailed testing at the time it occurs or go pull and inspect wires and switch and clean up the terminals.
|
02-23-2019, 06:14 PM | #3 |
Not Yet Wild
Join Date: Oct 2016
Posts: 73
|
Re: 05 precedent intermitently dies help please!!!!
I'll try another switch and check wires. Thanks
|
02-24-2019, 09:21 AM | #4 |
Not Yet Wild
Join Date: Jun 2011
Posts: 64
|
Re: 05 precedent intermitently dies help please!!!!
You might want to have a look at the terminals on the back of the key switch. Sometimes they come loose and can rotate causing intermittent problems. Good luck.
|
02-25-2019, 09:21 AM | #5 |
Not Yet Wild
Join Date: Oct 2016
Posts: 73
|
Re: 05 precedent intermitently dies help please!!!!
Tried new fwd rev switch and checked all connections and all good and it died again.after it sits couple hours it's fine
|
02-25-2019, 10:52 AM | #6 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: 05 precedent intermitently dies help please!!!!
If it is doing that and intermittently having only Fwd or Rev operable, then with it not being sonic weld, wiring or switch, it can only be a controller.
I would double check all my cables from the controller to the motor and if none are bad, I would be looking at a new XCT controller. Give David a call 706-431-3917 and see if he has any other suggestions. He will be your best deal for a new XCT controller also. |
02-25-2019, 11:02 AM | #7 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 05 precedent intermitently dies help please!!!!
Sounds like potentially a bad MCOR. The MCOR is the throttle switch mounted at the base of the accelerator pedal. Pull up the floor mat and pull out the two-pin connector from the MCOR. Use a piece of wire or a paperclip and jump the green wire to the blue with within the connector. If the vehicle operates normally with the jumper in place, replace the MCOR. Part number 102528501. Note that this is just for test procedures. If there is an internal throttle fluctuation within the throttle control circuit of the MCOR while the two-pin plug is bypassed, it may result in a runaway cart. I highly suggest turning OFF the key and putting the F&R switch in neutral while it is not being used to prevent this from happening.
|
02-25-2019, 01:39 PM | #8 |
Getting Wild
Join Date: Sep 2018
Location: Palm Harbor, FL
Posts: 86
|
Re: 05 precedent intermitently dies help please!!!!
That part makes it sound like something is heating up and causing problems then it's fine once it cools down. Maybe a terminal on a wire has too much resistance. I fought a similar problem, noticed that a specific battery terminal was getting way hotter than the others after a bit of use, so I replaced that battery cable and everything is fine now.
The faulty cable appeared fine, a visual inspection would not have caught this. |
02-28-2019, 07:09 AM | #9 |
Not Yet Wild
Join Date: Oct 2016
Posts: 73
|
Re: 05 precedent intermitently dies help please!!!!
Thanks for the replies,been driving it and now it won't fail but Still don't trust it
|
03-08-2019, 12:39 PM | #10 |
Not Yet Wild
Join Date: Oct 2016
Posts: 73
|
Re: 05 precedent intermitently dies help please!!!!
It finally died and I jumped mcor and it went.thanks Dave and everyone else .ill be ordering part as soon as I can.battery light flashed also can mcor do that
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Precedent randomly dies | Electric Club Car | |||
48V precedent bucks and dies | Electric Club Car | |||
96 gas melex cuts off intermitently | Gas golf carts | |||
g14 dies intermitently | Gas Yamaha |