|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
06-21-2019, 09:25 AM | #1 |
Not Yet Wild
Join Date: Jul 2016
Posts: 8
|
2009 EZGO PDS Issue
I have an EZGO 2009 PDS cart that has intermittent running issues. I have replaced the motor with a new stock replacement. I have replaced the controller with a reman from FSIP. New solenoid, New ITS, New speed sensor.
The cart is has a 6 inch lift with 22" tires with a rear seat. The cart runs good for 10 to 15 minutes and then starts going very slow. If I let it sit for a few minutes it takes back off and repeats this running behavior over and over. Any help would be greatly appreciated. Thank you in advance |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
06-21-2019, 10:31 AM | #2 |
Gone Wild
Join Date: Feb 2017
Location: Liberty Hill, Texas
Posts: 472
|
Re: 2009 EZGO PDS Issue
First step is to monitor battery pack voltage with a Digital Voltmeter set to display at least 2 decimal points (ex 38.39vdc)
Test and write down each battery and the whole pack, while the meter is connected to the whole pack, lets go for a ride while watching the pack voltage//// drive until the slowdown occurs, write down those voltages... Now come back with another post in this thread with the results.... IMHO it sounds like you have a battery or cable issue..... |
06-21-2019, 11:57 AM | #3 |
Gone Wild
Join Date: Sep 2016
Location: Northern California
Posts: 1,300
|
Re: 2009 EZGO PDS Issue
It also sounds like it could be a thermal shutdown issue. Are you getting any error codes when it shuts down? Is the controller hot when it quits going?
You've got 22" tires and a backseat. You are putting a bigger load on the cart than originally designed for. |
06-21-2019, 03:26 PM | #4 |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: 2009 EZGO PDS Issue
Put controller into diagnostic mode (Text at bottom of attached PDS label tells you how) and listen for beeped error codes while driving.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
2009 EZGO RXV Charging issue | Electric EZGO | |||
2009 RXV Charging issue | Electric EZGO | |||
2009 RVX bearing issue | Electric EZGO | |||
2009 RXV 4-way switch issue | Electric EZGO | |||
2009 ezgo txt charger/battery issue | Electric EZGO |