|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
10-08-2013, 05:40 AM | #1 |
Not Yet Wild
Join Date: Oct 2013
Location: Ohio
Posts: 11
|
2007 48 volt iq ds very short run time
I have a 2007 Club car 48 volt DS IQ and the run time is very short. New US batteries last year. Had the cart along with the charger and batteries checked by a local service shop and they said that everything is good. Cart will run for 10-15 minutes and is dead. The battery warning light comes on flashes once and then the cart is dead. Any help would be appreciated.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
10-08-2013, 07:02 AM | #2 |
Medicare Recipient
Join Date: Jun 2011
Location: West Michigan
Posts: 3,541
|
Re: 2007 48 volt iq ds very short run time
. . . usually the battery warning light illuminates during operation to indicate a low battery condition . . . when you took batteries to shop, how did they test them? Did they check the SG of each individual cell? Sounds like you may have some bad one(s) . . .
|
10-08-2013, 08:50 AM | #3 |
Not Yet Wild
Join Date: Oct 2013
Location: Ohio
Posts: 11
|
Re: 2007 48 volt iq ds very short run time
They checked the S/G and load tested them also. When the light comes on it only flashes on time and that is it.
|
10-08-2013, 09:01 AM | #4 |
......................
Join Date: Apr 2009
Location: FT Lauderdale FL.
Posts: 16,416
|
Re: 2007 48 volt iq ds very short run time
Welcome to BGW
you say 10-15 minutes and it is dead, what is the battery pack volts when you say it's dead, when you say dead, does this mean that the cart will not move/do anything?, or does it run slow/like 2 MPH?? |
10-08-2013, 09:22 AM | #5 |
Not Yet Wild
Join Date: Oct 2013
Location: Ohio
Posts: 11
|
Re: 2007 48 volt iq ds very short run time
Cart runs very slow. Not sure what the volts are.
|
10-08-2013, 10:56 AM | #6 |
Gone Wild
Join Date: Aug 2009
Posts: 14,245
|
Re: 2007 48 volt iq ds very short run time
Take the pack voltage. New batteries can have bad cells. It happened to me once.
|
10-08-2013, 11:30 AM | #7 |
Not Yet Wild
Join Date: Oct 2013
Location: Ohio
Posts: 11
|
Re: 2007 48 volt iq ds very short run time
ok, I will check. Thanks
|
10-09-2013, 04:59 AM | #8 |
Medicare Recipient
Join Date: Jun 2011
Location: West Michigan
Posts: 3,541
|
Re: 2007 48 volt iq ds very short run time
. . . failing speed sensor? ... though limp mode would be about 8mph . . .
|
10-10-2013, 03:04 AM | #9 |
Not Yet Wild
Join Date: Oct 2013
Location: Ohio
Posts: 11
|
Re: 2007 48 volt iq ds very short run time
I tried 2 different chargers to make sure that the charger was not the problem. The batteries are US Battery 12V XC. The post has a E1 on it, I assume that they were made in May of 2011. The dealer installed them in March of 2012. The pack voltage is 48.2 volts. I tried to check the specific gravity and it won't register on the refractometer. When I had the service guy check them he said that they were 95% and needed to be charged and discharged several times to get the optimal preformance. That was about 3 months ago. Is it possible that all 4 batteries would go at the same time?
|
10-10-2013, 06:04 AM | #10 |
Medicare Recipient
Join Date: Jun 2011
Location: West Michigan
Posts: 3,541
|
Re: 2007 48 volt iq ds very short run time
. . . 48.2v is around 50% charged . . .
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Yamaha g1 stops after a short time | Gas Yamaha | |||
Pds cart with short run time | Electric EZGO | |||
2004 EZ-GO TXT Electric Cart randomly stops for short time | Electric EZGO | |||
Short run time after new Batt & Controller | Electric Club Car | |||
short in 48 volt club car '95... | Electric Club Car |