|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
08-05-2017, 08:23 AM | #1 |
Not Yet Wild
Join Date: Nov 2016
Posts: 10
|
1987 easy go speed surge
Hi,I have a '87 easy go gas 2 cycle that is having speed surges after running 15-30 min? It feels like slippage but not certain if its gas related or clutch slipping or even rear end? I put a new drive belt on yesterday "which did have wear" but still surging after running a few minutes, I added 80-90 wt. rear end oil, "no help" I would really appreciate any suggestions on what direction to go!
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-05-2017, 08:26 AM | #2 |
Gone Wild
Join Date: Feb 2008
Location: Brooklyn, Michigan "Home of M.I.S."
Posts: 3,667
|
Re: 1987 easy go speed surge
Could it be the governor?
|
08-05-2017, 11:05 AM | #3 |
Not Yet Wild
Join Date: Nov 2016
Posts: 10
|
Re: 1987 easy go speed surge
Haven't checked the governor guess it could be only it runs and performs as it should until it maybe 1-2 miles on it?Thanks
|
08-05-2017, 12:35 PM | #4 |
Test before replacing
Join Date: Aug 2013
Location: Ohio side of the Pennsylvania border.
Posts: 3,496
|
Re: 1987 easy go speed surge
See what happens when you loosen the gas cap.
If that doesn't help, it might be a heat problem. There is tin work around the fins. It needs to be in place, and the fins need to be clean, and clear. After that, I would look at loss of spark from heat. Could be plug, wire, or coil. |
08-05-2017, 01:27 PM | #5 |
Not Yet Wild
Join Date: Nov 2016
Posts: 10
|
Re: 1987 easy go speed surge
That makes two of us,the belt was hard/cracked,so it needed replacing bur did not resolve this surging but I keep trying to connect with the fact that it has to have something to do with the heating up,thought the old belt may have been slipping inside the flanges. I'm going to try it this pm with the gas cap loose.fuel pump could be getting weak? Thanks
|
08-05-2017, 04:19 PM | #6 |
Not Yet Wild
Join Date: Nov 2016
Posts: 10
|
Re: 1987 easy go speed surge
Got this on my 1st thing do do list, I will check all that you mentioned. Thank you very much and I will let you know. Thanks again
|
08-05-2017, 04:22 PM | #7 |
Not Yet Wild
Join Date: Nov 2016
Posts: 10
|
Re: 1987 easy go speed surge
Type"o" to do list.
|
08-09-2017, 09:29 AM | #8 |
Test before replacing
Join Date: Aug 2013
Location: Ohio side of the Pennsylvania border.
Posts: 3,496
|
Re: 1987 easy go speed surge
What were the results of the things you were going to check?
Does the engine rev up, or die down? Does it sound like it's sputtering? Did you try jiggling the handle? Does it run strong before this surging happens? Hard to say without hearing it run. Maybe something as simple as a spark plug. |
08-09-2017, 10:28 AM | #9 |
Not Yet Wild
Join Date: Nov 2016
Posts: 10
|
Re: 1987 easy go speed surge
After running a few minutes the RPM's seem to speed up without accelerating with the pedal the slow back down less than the applied acceleration and if I release the pedal all together it stops hard like putting on the brake, before this starts it runs strong and good,you can hear rpm increase in the engine for a second and decrease for a second, seems to be worse at slower speed? I am in hopes that it isn't in the clutch system $$$ Thanks oh I loosened the gas cap and cleaned the fins out also. The handle you are refering to is the forward/reverse? If so I have not done that.
|
08-09-2017, 03:33 PM | #10 |
Test before replacing
Join Date: Aug 2013
Location: Ohio side of the Pennsylvania border.
Posts: 3,496
|
Re: 1987 easy go speed surge
Jiggling the handle was just a joke.
Take the ferule off of the governor cable to disconnect it at the carburetor. I have company that just showed up. Will be back later. |
|
|
Similar Threads | ||||
Thread | Forum | |||
G31 AJP - how easy is it to speed this up! | Electric Yamaha | |||
2002 speed surge problem | Electric EZGO | |||
easy speed for non pds? | Electric EZGO | |||
83 ez go..looking for easy speed | Electric EZGO | |||
Low Speed Surge | Gas EZGO |