|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
07-25-2019, 03:40 AM | #1 |
Gone Wild
Join Date: May 2009
Posts: 377
|
Rxv driven clutch noise
I've just got a 2012 Rxv . It has a noise from the driven clutch as I slow down to stop.All clutch sheaves look fine, shiny, and clean, it’s an annoying creaking/pinging noise It sounds like an elastic band twang or a creaking/pinging spring. I power washed the cart inside and out and washed the driven clutch good and the noise went away for awhile I’m guessing until it dried out now it’s back.i tried spraying some lube into but no luck. Any ideas of a cure or the problem? Thanks for now!
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-25-2019, 05:33 AM | #2 |
Gone Wild
Join Date: Jun 2011
Location: Northern Indiana
Posts: 2,813
|
Re: Rxv driven clutch noise
I've seen several of those driven clutches wear out the groove where the snap ring holds the inward portion of the clutch in place on the center shaft. Eventually the snap ring pops out and the back/inward portion pops up against the transaxle housing and won't let the input shaft turn.
While you're ay it check/tighten the nuts on your rear hubs, where the splined axle shaft goes through the brake drum. Those are known to work loose over time and eventually strip the splines out of the drum. Often the first sign is that creaking noises. |
07-25-2019, 05:56 AM | #3 |
Gone Wild
Join Date: May 2009
Posts: 377
|
Re: Rxv driven clutch noise
Thanks alot for the info I will check all that out later today.
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
1998 g16 secondary driven clutch noise | Gas Yamaha | |||
1983 ezgo driven clutch noise or ? | Gas EZGO | |||
Bad vibration/noise from driven clutch at higher speeds.. | Gas EZGO | |||
Driven Clutch Making Noise | Gas Club Car | |||
Driven clutch noise? | Gas Club Car |