|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
11-10-2020, 07:27 PM | #1 |
Not Yet Wild
Join Date: Nov 2020
Posts: 1
|
G22A Crank No Go, started while in operation
So last night we were out riding our 2003 G22A Yamaha Gas Cart for about 30 mins and while in operation, the cart died out. With the gas pedal engaged it was still cranking but not going.
Today I checked the plug, had spark. Checked the fuel pump and it was pumping. I cleaned the carb and still the same. Any tips, advise or help is greatly appreciated. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
11-10-2020, 07:32 PM | #2 |
Gone Wild
Join Date: Jun 2011
Location: Northern Indiana
Posts: 2,827
|
Re: G22A Crank No Go, started while in operation
Check compression.
|
11-11-2020, 07:11 AM | #3 |
maintaining a low profile
Join Date: Oct 2009
Location: SW Virginia USA
Posts: 6,316
|
Re: G22A Crank No Go, started while in operation
Throttle cable...
|
11-11-2020, 08:07 AM | #4 |
Searching for The Way
Join Date: Oct 2009
Location: Medina, Ohio (NEOHIO)
Posts: 11,441
|
Re: G22A Crank No Go, started while in operation
1. Spark - looking for a bright blue/white spark
2. Fuel - looking for fuel pumping at the carb hose 3. Air - good clean air filter 4. Compression - check specs in service manual 5. Timing - spark must be timed with the engine 6. Carburetor - fuel must flow into the bowl, throttle works, clean not plugged 7. Starting system - good battery, starter, and cables, good rpm during starting If you are missing any one of these, the cart will not run. |
|
|
Similar Threads | ||||
Thread | Forum | |||
Operation Help Thy Neighbor | Electric EZGO | |||
Solenoid operation ? | Electric EZGO | |||
Does a 2pg have a crank case pressure pickup tube inside the crank case? (pic) | Gas EZGO | |||
aligment of cam shaft, crank, and crank balance on g14 | Gas Yamaha | |||
trans operation. | Gas EZGO |