|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
07-16-2016, 09:34 AM | #1 |
Not Yet Wild
Join Date: Jun 2016
Location: SW NE Iowa
Posts: 3
|
'91 G9 bogging down after being run (sometimes)
I purchased a used '91 G9 this spring. Since the previous owner responded "I don't know" to every service question, (local high school shop teacher runs a spring oil change program so I know that was done & oil was clean) I replaced the fuel tank filter, both belts, checked the fuel pump, replaced all fuel lines and impulse line, air filter, spark plug and cleaned out the carburetor. I will run fine for about 7-8 holes but then it would bog down and barely limp along. This goes one for 5-10 minutes and then it snaps out of it and run strong. Only thing I observe is a very hot muffler. The other great thing is that it does not do this every time out and weather conditions don't seem to affect it as I ran 18 holes in 95 degree temps and it never missed a beat.
I have double checked the air filter box and it is on correctly. Wiring looks good and I am running straight gas, no 10%. I did disconnect the governor by re-routing the throttle cable straight to the carburetor and the carb does close all the way when the pedal is not pressed. What else could I be missing? John |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-16-2016, 09:41 AM | #2 |
Gone Wild
Join Date: Nov 2013
Posts: 1,088
|
Re: '91 G9 bogging down after being run (sometimes)
First thought would be ignitor.get a spark tester if you don't already have one $5-10 at parts store.when it starts running like that plug it in and watch the spark if it's dim or flickering you probably need an ignitor good luck and keep us posted
|
07-16-2016, 10:52 AM | #3 |
Not Yet Wild
Join Date: Jun 2016
Location: SW NE Iowa
Posts: 3
|
Re: '91 G9 bogging down after being run (sometimes)
Thanks. I will try that.
|
08-27-2016, 02:53 PM | #4 |
Not Yet Wild
Join Date: Jun 2016
Location: SW NE Iowa
Posts: 3
|
Re: '91 G9 bogging down after being run (sometimes)
Thanks for the advise. Spark was weak and a new ignitor fixed the glitch.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
'98 TXT Bogging....sometimes? | Electric EZGO | |||
bogging 86 yamaha | Gas Yamaha | |||
Bogging down | Gas Yamaha | |||
Help - 2 stroke bogging down | Gas EZGO | |||
86 Ez Go Bogging Down | Electric EZGO |