|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
07-28-2015, 05:04 PM | #1 |
Not Yet Wild
Join Date: Sep 2011
Posts: 33
|
Ezgo PDS Motor
I have tested FI & F2 and A1 & A2 and there were no problems. I did find F1 and F2 were showing some small amount of short to the housing. The cart was running and then stop. I have check all wires and tested everything and everything is testing ok. Is this motor bad?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-29-2015, 12:37 PM | #2 |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: Ezgo PDS Motor
Carbon dust from brush wear will create some continuity between the windings and the case.
The carbon dust buildup will reduce the efficiency of the motor (due to some of the amps bypassing the windings), but won't cause the motor to stop running. The motor may need a new set of brushes and a good cleaning, but probably isn't bad. ------------- Does the solenoid click when you push the pedal? If so, there is a problem in the high-current circuit. If it doesn't click, there is a problem in the solenoid activation circuit. A very common problem is a bad reed switch, so check to see if you have pack voltage on the smaller of the three wires coming out the backside of the charger receptacle. |
07-29-2015, 07:52 PM | #3 |
Not Yet Wild
Join Date: Sep 2011
Posts: 33
|
Re: Ezgo PDS Motor
Thanks The solenoid does click and I do have battery voltage on small wire from charger port. I have check the accelerator switch and speed coil and they tested ok. I have put the cart in the diagnosis mode and it gave me 4 beeps. I check the voltage on controller and do not find a problem. Would the speed senser give this problem?
|
07-29-2015, 08:07 PM | #4 |
Not Yet Wild
Join Date: Sep 2011
Posts: 33
|
Re: Ezgo PDS Motor
Could this controller go into a low voltage shut down and it so how do you bring it back?
|
07-30-2015, 07:12 AM | #5 | ||
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: Ezgo PDS Motor
Quote:
Four beeps when it goes into diagnostics means it is in the "Freedom" mode. When any additional beeps heard when you drove the cart in diagnostic mode? Quote:
Flipping the Run/Tow switch to Tow, waiting a moment and putting back into Run will reset the controller. |
||
07-30-2015, 09:05 AM | #6 |
Not Yet Wild
Join Date: Sep 2011
Posts: 33
|
Re: Ezgo PDS Motor
I have 38 volts and I have check the ITS and it has 38 volts to switch and o to 128 on black and the white wire when pedal is press. The cart will not move so I do not here any beeps. I have had the run / tow off and check and have switch it many times. Pull cables from motor today and jump it and it ran so I must have a bad controller.
|
07-30-2015, 09:57 AM | #7 |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: Ezgo PDS Motor
Replace the controller with an Alltrax XCT48400PDS. It will up the speed to about 24 MPH on stock height (18") tires at 36V.
|
07-30-2015, 09:58 AM | #8 | |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,419
|
Re: Ezgo PDS Motor
Quote:
|
|
07-30-2015, 10:23 AM | #9 |
Not Yet Wild
Join Date: Sep 2011
Posts: 33
|
Re: Ezgo PDS Motor
Thanks guys I guess I will spend some money
|
07-30-2015, 10:58 AM | #10 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,419
|
Re: Ezgo PDS Motor
Take a look at the new XCT control for PDS before you make a decision. Here > http://www.buggiesgonewild.com/elect...xct400pds.html
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Anybody got a used EzGo PDS Motor??? | Golf Carts and Parts | |||
Yamaha G16 Motor Coupling Squealing, Will my old EZGO motor work? | Electric Yamaha | |||
Help with an old ezgo motor (6 wire motor) | Electric EZGO | |||
New EZGO 36V motor $375 | Golf Carts and Parts | |||
EZGO Workhorse 6 PASSENGER limo Setup for Briggs,Honda or Ezgo Motor | Golf Carts and Parts |