|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
07-18-2015, 09:08 PM | #1 |
Getting Wild
Join Date: Jun 2015
Location: Ticonderoga Ny.
Posts: 126
|
Oil in air box ??
Hello peep's,
today i tried starting my G2 with no luck :(. so i started trouble shooting, Found that it would start with air box tube removed. but smoking bad. So i check alittle deeper & found the air box was filled with oil... this means i'm getting blow by ??.. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-18-2015, 09:33 PM | #2 |
G8 Specialist
Join Date: Jun 2009
Location: Phoenix
Posts: 7,799
|
Re: Oil in air box ??
It usually means you had to much oil in the motor. Drain and one quart only!! That is your new full mark on the dip stick!!
Now you probably need to buy a new air filter!! |
07-19-2015, 03:42 PM | #3 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: Oil in air box ??
A great cause of overfilled crankcase is a bad needle valve in carb causing unburned fuel to contaminate/dilute the oil.
|
07-21-2015, 01:44 PM | #4 |
Vegas modded 420
Join Date: Jun 2009
Location: West MI
Posts: 15,443
|
Re: Oil in air box ??
Yep, overfill of oil will puke out the airbox. Blowby of worn motor will make a little come out not much. You can also clean that valve in the hose on the passenger side of the cylinder, its like a pvc valve, and its one way so put back in the same way. If oil reeks of gas you have a bad float/valve leaking into the engine.... just like those guys say.
|
07-21-2015, 02:37 PM | #5 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: Oil in air box ??
I have also seen carts used for only short trips do this, the engine never spends much time at normal operating temp.
|
07-21-2015, 08:20 PM | #6 |
Getting Wild
Join Date: Jun 2015
Location: Ticonderoga Ny.
Posts: 126
|
Re: Oil in air box ??
Thanks guy's,, i just pulled the little 4 stoke .. Adding a yammy 340cc ... pics in members carts ... Thanks again Bill
|
07-21-2015, 08:46 PM | #7 |
Not Yet Wild
Join Date: May 2015
Location: NH
Posts: 68
|
Re: Oil in air box ??
I saw on Youtube that if the governor is backed off too much it causes the same problem.
|