11-03-2019, 02:43 PM | #1 |
Not Yet Wild
Join Date: Nov 2019
Posts: 2
|
Gas club car won't rev up
Hi all, this is my first post so hopefully it's in the right spot.
I've been pulling my hair out with my club car. Last week I pulled the starter off to clean the brushes and then re-installed it, it ran great for a few minutes then ran out of gas, since I refilled it, the engine will, at best, idle a bit. It has no power and won't drive. Kawasaki fe290 1995 I replaced the gas again. New carburator Removed air cleaner Compression is 155 Oil is at dipstick low level I removed the ground wire to the rpm limiter to see if this affected it ( no change) New spark plug Fuel pump has continuous fuel coming out of the tube. Not super strong but does come out. I bypassed the fuel pump and handfeed had into the carb (no change) Spark at the boot ( that the spark plug, plugs into) jumps a 3/8" Gap This seems sufficient, but I heard a white spark may not work under compression and I may need a new coil? Valves move up and down, and have a gap, I didn't check with feeler gauges, but there is a gap It seems as though there is no gap between the spark at the plug, it rapid fires very quick, faster than I think the Piston would cycle 4 strokes. Thanks for any suggestions!! |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
11-04-2019, 09:12 PM | #2 |
Gone Wild
Join Date: Apr 2012
Location: s e mo
Posts: 169
|
Re: Gas club car won't rev up
Unless you got carb from a known working cart or new from cc dealer,It could still be the problem. If you don't have air cleaner hooked up,you need to partly cover air going to carb.
Sent from my Lenovo TAB 2 A7-30F using Tapatalk |
11-05-2019, 10:48 AM | #3 |
Not Yet Wild
Join Date: Aug 2019
Posts: 63
|
Re: Gas club car won't rev up
Do a compression test
Sent from my iPhone using Tapatalk |
11-10-2019, 05:08 PM | #4 |
Not Yet Wild
Join Date: Nov 2019
Posts: 2
|
Re: Gas club car won't rev up
Compression is 155lbs
I did cover the carb a bit with my hand. Slight change but barely. I'm thinking now maybe the coil is shot even though it still throws a spark??? |
11-13-2019, 05:05 PM | #5 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: Gas club car won't rev up
Spray some starting fluid into the carburetor and see if it'll run on that. If you bought a cheapo aftermarket carb from eBay or Amazon that may be your issue. A lot of them are bad right out of the box.
|
11-13-2019, 06:04 PM | #6 |
Gone Wild
Join Date: Jun 2011
Location: Northern Indiana
Posts: 2,827
|
Re: Gas club car won't rev up
Have you checked or replaced the spark plug itself?
|