|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
09-22-2013, 11:30 PM | #1 |
Not Yet Wild
Join Date: Aug 2013
Posts: 5
|
93 ezgo 4 stroke smells like gas fumes
My 93 ezgo 295 is freshly rebuilt. Carb is clean. Valves are adjusted. Cleaned fuel tank. Seems to run good but smokes when you take off or drive slowly. Smells like fuel smoke and really stinks and burns your eyes when you drive down road. I appreciate Any help. Thanks
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
09-24-2013, 01:26 PM | #2 |
Not Yet Wild
Join Date: Aug 2012
Location: PA
Posts: 68
|
Re: 93 ezgo 4 stroke smells like gas fumes
what color is the smoke? blue or white?
Were the pistons/ rings replaced during the rebuild? if so maybe yours is smoking because the rings just need to seat. and until then it will smoke. My 94 4-stroke did that after the rings/pistons were replaced. from what ive been told it will stop smoking as the rings seat. *just going off of what ive been told so i could be wrong* |
09-24-2013, 02:38 PM | #3 |
Not Yet Wild
Join Date: Aug 2013
Posts: 5
|
Re: 93 ezgo 4 stroke smells like gas fumes
Yes it has new pistons rings rods and everything. Bored 50mm oversize. Never built any golf cart engine but have built hundreds of automobile engines. I was very careful to read all instructions in the rebuild manual I downloaded. It may just need to seat rings. I'm not sure. But I still am wandering about the gas smell. Very rich smelling. Color I think is blue smoke. Ill double check that. Haven't really paid attention to the color yet.
|
09-24-2013, 02:39 PM | #4 |
Not Yet Wild
Join Date: Aug 2013
Posts: 5
|
Re: 93 ezgo 4 stroke smells like gas fumes
By the way. Thanks for your response.
|
09-24-2013, 09:34 PM | #5 |
Not Yet Wild
Join Date: Aug 2012
Location: PA
Posts: 68
|
Re: 93 ezgo 4 stroke smells like gas fumes
No problem, sorry i couldnt provide a more straight forward answer/ solution. if the smoke is blue i believe i read somewhere that it means its burning oil? hopefully someone else will chime in.
Not sure about the gas smell, sorry! good luck and hopefully its just the rings and it will go away after you drive it a while. |
Tags |
carb, fuel mixture, fumes |
|
|
Similar Threads | ||||
Thread | Forum | |||
1988 ezgo 2 stroke to 4 stroke questions | Big Block Talk! | |||
exhaust fumes | Gas EZGO | |||
88 ezgo 2 stroke convert to 4 stroke | Gas EZGO | |||
can i use 2 stroke ezgo clutch on 4 stroke | Big Block Talk! | |||
1986 EZGO Marathon surges @low speed,smells of gas | Gas EZGO |