06-03-2019, 05:57 PM | #11 |
Gone Insane
Join Date: Oct 2016
Location: Richmond, VA
Posts: 14,214
|
Re: AG02 DS Won't Shut Off
Yes it was running. I drove it several miles yesterday just to get some run time on it because it has not been used much. Went outside to move it this afternoon and it will not start. Not getting fire.
To recap, yesterday it would run fine and not turn off. Kept running (moving) with foot off pedal. Had to turn key off to make it stop. Sat overnight and today has no spark. SG spinning fine. I'm thinking the 2 issues have to be related. Thoughts? |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
06-03-2019, 06:14 PM | #12 |
Bonafide Nincompoop
Join Date: Dec 2015
Location: Charlottesburg Va
Posts: 8,987
|
Re: AG02 DS Won't Shut Off
Kinda seems like a bad ignition kill MS on the throttle cam.
If it's not that then it's the Key switch or a bad wire or connection somewhere in between. You can check for continuity to ground at the microswitch white/black wires with the key switch on and off. The wire on the side pin should go to the key switch. If you have no continuity there, test the M+ terminal on the key switch. If you have continuity on the side pin, test the middle pin and work the throttle cam to make sure it changes when the switch opens/closes. If it doesn't change, the MS is bad. That should be right but it's been a long day. Worst case, microswitches are pretty cheap so you can swap it just for giggles and see what happens. |
06-03-2019, 08:03 PM | #13 |
Gone Insane
Join Date: Oct 2016
Location: Richmond, VA
Posts: 14,214
|
Re: AG02 DS Won't Shut Off
Well I got fire. Cart runs with plenty of power. I decided to switch out the bottom micro even though it was clicking. They both looked as though they came with the cart so I switched them both out. I don't have any 2 prong micro switches so so thought I could use 3 prong and just figure out what needed to go where.
Started playing with them and switching things around. As I tell this story I'm still a bit shook up and can't remember if the key switch was on or not. Plugging the wires onto the MS prongs the cart not only fired up but the throttle must have been stuck 1/2 to 3/4 open. Took off throwing me out of the way as I was leaning in there hooking up the wires. Ran through a fence between my property and a convenience store next door. Went about another 40-50 feet and slammed into the side delivery entrance doors and a 12" cinderblock wall. Thank God nobody was parked/walking through that area at a busy time of the day. I'm a bit scraped up but OK. |
06-03-2019, 08:52 PM | #14 |
Bonafide Nincompoop
Join Date: Dec 2015
Location: Charlottesburg Va
Posts: 8,987
|
Re: AG02 DS Won't Shut Off
Glad to hear you’re ok bud! That’s a scary experience for sure! Definitly not something you expect to happen, but I guess all accidents are like that.
But since nobody got hurt... Wooooo!!! what a ride!!!! |
06-03-2019, 09:05 PM | #15 |
Gone Insane
Join Date: Oct 2016
Location: Richmond, VA
Posts: 14,214
|
Re: AG02 DS Won't Shut Off
LOL. Yeah. Even with the throttle being out of adjustment. I had to start it with the pedal. But not thinking about the MS having to be clicked "in" as it would be when pedal is released killing the fire, I hooked the wires without the switch being "seated" where they should be in the box and the switch depressed killing the fire. I know it was in gear, the keyswitch must have been on too.
Bet I don't do this again! |
06-03-2019, 09:27 PM | #16 |
Gone Insane
Join Date: Oct 2016
Location: Richmond, VA
Posts: 14,214
|
Re: AG02 DS Won't Shut Off
Could have been worse.
|
06-03-2019, 10:05 PM | #17 |
Nincompoop village idiot
Join Date: Apr 2018
Location: Michigan
Posts: 9,673
|
Re: AG02 DS Won't Shut Off
WOW. Glad you're okay.
Since you're okay, a little levity perhaps... point it at a pond next time and you won't have to worry about the microswitches anymore |
06-03-2019, 10:08 PM | #18 |
Gone Insane
Join Date: Oct 2016
Location: Richmond, VA
Posts: 14,214
|
Re: AG02 DS Won't Shut Off
|
06-04-2019, 06:29 AM | #19 |
Gone Wild
Join Date: Jun 2017
Location: Savannah, GA
Posts: 6,539
|
Re: AG02 DS Won't Shut Off
I’m always afraid of this but never had it happen. I’m just as lazy as the rest when it comes to jack stands! Glad you’re ok though...
|
06-04-2019, 07:31 AM | #20 | |
Nincompoop village idiot
Join Date: Apr 2018
Location: Michigan
Posts: 9,673
|
Re: AG02 DS Won't Shut Off
Quote:
Also good to prank your brother since it wont run while in gear. He'll never figure out why it will run in neutral but wont run in forward or reverse to drive it |
|
|
|
Similar Threads | ||||
Thread | Forum | |||
G1 will not shut off | Gas Yamaha | |||
shut down of rxv | Electric EZGO | |||
G16 won't shut off? | Gas Yamaha | |||
EZ GO ST 350 won't shut off | Gas EZGO | |||
Will not shut off. | Gas Club Car |