|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
05-11-2018, 05:33 PM | #1 |
Not Yet Wild
Join Date: May 2018
Posts: 17
|
1995 Club Car DS runs for 5 minutes and then stalls...
Hello
Please help with this one. The cart runs great for about 5 minutes or 1/2 mile. Then it will either start stuttering or just stop all together (when I press the gas it just makes the sound without movement). If it sits for 5 minutes, it will go again for 30 seconds and then sputters and back fires at about max of 3 MPh) Because of that, I changed the spark plug, fuel filters, and cleaned the fuel pump. I am wondering if it’s the carb needs cleaning or the speed sensor? Could a dirty carb cause this? Of course it’s the first real use after “winter.” One more odd thing....I washed the cart and it started after that, so wondered if something got wet that shouldn’t have (it was a few weeks ago and has still does it). Appreciate any help!! |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
05-11-2018, 06:17 PM | #2 |
Gone Wild
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,669
|
Re: 1995 Club Car DS runs for 5 minutes and then stalls...
Need to figure out if it's fuel or ignition... Run the cart until it acts up pull the spark plug right away and inspect it if it's wet it's ignition issue if it's dry it's fuel issue and we can go from there
|
05-11-2018, 07:22 PM | #3 |
Getting Wild
Join Date: May 2017
Location: stl mo
Posts: 113
|
Re: 1995 Club Car DS runs for 5 minutes and then stalls...
Buy an inline spark tester.. When it acts up, your probably losing Spark, due to heat-related failure.
Mine was the coil, but it could be the rev limiter. The rev limiter will be in the front of the motor pull the ground off and tape it up so it does not ground out, this should disable the rev limiter completely. Test drive it if it cuts out again then it's the coil Sent from my Nexus 6P using Tapatalk |
05-12-2018, 09:48 AM | #4 | |
Not Yet Wild
Join Date: May 2018
Posts: 17
|
Re: 1995 Club Car DS runs for 5 minutes and then stalls...
Quote:
I really appreciate the time in your responses!!! |
|
05-12-2018, 10:29 AM | #5 |
Getting Wild
Join Date: May 2017
Location: stl mo
Posts: 113
|
Re: 1995 Club Car DS runs for 5 minutes and then stalls...
I guess it could be, but really sounds heat related to me.
You can pull the fuel line off at the carb and see if you have gas bubbling out in pulses, that would tell you if your fuel pump is working... That rubber from your fuel cap is now out the tank, could be clogging the pick up hose.... But sound just like what my 99cc did when I got it, mine was a bad coil, at one point they had separate igniter from the coil, I guess it could be that... It really sounds like heat to me though, cart does fine too it heats up, coil quits working You lose Spark, car cools down fires up and goes again Sent from my Nexus 6P using Tapatalk |
05-12-2018, 10:43 AM | #6 |
Gone Wild
Join Date: Jun 2011
Location: Northern Indiana
Posts: 2,823
|
Re: 1995 Club Car DS runs for 5 minutes and then stalls...
If the 95 is still stock it would have the separate coil and igniter. They do commonly break down from heat, so yes that is a possibility. However, since you mentioned the gas cap gasket missing jdgriner is right that the little pieces that used to be the cap gasket are now at the bottom of your fuel tank just waiting to get sucked into the pick up tube and plug it off.
|
05-12-2018, 12:13 PM | #7 |
Gone Wild
Join Date: Dec 2009
Location: Aiken, SC
Posts: 13,141
|
Re: 1995 Club Car DS runs for 5 minutes and then stalls...
Also try running it with the gas cap off. May be a bad vent or lack there of.
|
05-12-2018, 02:05 PM | #8 | |
Not Yet Wild
Join Date: May 2018
Posts: 17
|
Re: 1995 Club Car DS runs for 5 minutes and then stalls...
Quote:
The rubber from the cap was vac’ed out and all lines, fuel filtered replaced, and fuel pump cleaned it. Just took off the carb and it is spotless. Sounds like I’m down to Rev limiter (did it while ground unhooked, so not sure?), coil, and igniter (that sits behind the rev limiter). It sure there is a whole lot else besides the way something is set that may cause it. The new plug is gapped correctly as well. Is 91 degrees today....thinking I need my garage air conditioned!! Thanks again guys! |
|
05-14-2018, 07:16 AM | #9 |
Gone Wild
Join Date: Jun 2011
Location: Northern Indiana
Posts: 2,823
|
Re: 1995 Club Car DS runs for 5 minutes and then stalls...
Just a couple things: If it did the same thing with the RPM limiter ground unhooked the RPM limiter is NOT the problem. If you've unhooked that limiter, you can get rid of it and the bracket it mounts to. The ignitor doesn't HAVE to mount to the factory position to work. I've often run a slightly longer wire and mounted it at the oil tube hold down. Much easier to reach if needed.
|
05-15-2018, 04:42 PM | #10 | |
Not Yet Wild
Join Date: May 2018
Posts: 17
|
Re: 1995 Club Car DS runs for 5 minutes and then stalls...
Quote:
Please see the link to what I had today. I had the gas down almost all the way. It would sputter and then go again....then sputter. The fuel lines are clean and the rev limiter still taped off. Just wanted to get your opinion after hearing it. Next move is to buy a new coil and igniter....separate on my 1995. https://www.youtube.com/watch?v=2v0eZHWS9ms Thanks guys!! |
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Runs 10 minutes then shuts off, wait 5 then runs again... | Electric EZGO | |||
1995 Club Car Only Runs With Açcelerator Pedal Fully Depressed | Electric Club Car | |||
G2 runs hot and stalls | Gas Yamaha | |||
89 marathon runs stalls runs stalls | Gas EZGO | |||
Charge 4 Hrs-Runs 30 Minutes | Electric EZGO |