|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
05-09-2011, 07:48 PM | #1 |
Not Yet Wild
Join Date: Dec 2008
Posts: 22
|
Help with G16 A!!!
Alright guys we have re built the whole rearend and got it back under the frame. and we get everthing hooked up and we turn the key and it turns over but no start!!! Have no idea what the problem is, checked the spark plug and its got spark. The carbs got gas in it. No idea whats wrong please help!
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
05-09-2011, 11:35 PM | #2 |
G8 Specialist
Join Date: Jun 2009
Location: Phoenix
Posts: 7,799
|
Re: Help with G16 A!!!
I would say either no compression or out of time.
|
05-10-2011, 05:33 AM | #3 |
Gone Crazy
Join Date: Jan 2007
Location: Chesterfield, Va
Posts: 6,021
|
Re: Help with G16 A!!!
All you did was rebuild the rear axle?
Was it running before you worked on it? Try a new spark plug? |
05-10-2011, 05:53 AM | #4 |
Not Yet Wild
Join Date: Dec 2008
Posts: 22
|
Re: Help with G16 A!!!
It was running prior to the rebuilding the rear end/governor. The cart has been sitting for about 8 months. Could it be the battery? My son has bypassed the foot switch and when you turn the key to on it will run for a short time. However when you hit the gas pedal, I get nothing. Tried to jump start but no luck. Any ideas?
|
05-10-2011, 06:07 AM | #5 |
Gone Crazy
Join Date: Jan 2007
Location: Chesterfield, Va
Posts: 6,021
|
Re: Help with G16 A!!!
When you say "run" for a short while, is it running and reving up or just the starter spinning it over?
Need to charge the battery fully if it is in question and change the fuel. |
05-10-2011, 06:16 AM | #6 |
Not Yet Wild
Join Date: Dec 2008
Posts: 22
|
Re: Help with G16 A!!!
The starter is just turning the motor over... I will charge the battery and try that.
|
05-10-2011, 08:18 PM | #7 |
Gone Wild
Join Date: Nov 2010
Location: Havana Illinois
Posts: 156
|
Re: Help with G16 A!!!
Are you pulling the choke. My G16 doesn't want to start if it is cold without the choke.
|
05-11-2011, 05:41 AM | #8 |
Not Yet Wild
Join Date: Dec 2008
Posts: 22
|
Re: Help with G16 A!!!
When turning the key on, the starter kicks in and runs the cart. Hit the gas pedal and nothing happens the cart still runs only from the battery. Charged the battery and ran the fuel line from the gas tank directly to a gas can. Still nothing..... Could it be the fuel pump? How do you test the fuel pump? I am struggling....
|
05-11-2011, 05:50 AM | #9 |
Gone Crazy
Join Date: Jan 2007
Location: Chesterfield, Va
Posts: 6,021
|
Re: Help with G16 A!!!
So you are not getting fuel from the fuel line that you removed from the carb, correct?
1st, check the hose between the pump and motor for cracks or loose fit, that works the pump from crankcase pressure pulses. Remove the fuel line from the carb again and with air hose, blow slowly into gas tank filler with rag wrapped around blower, fuel should come out of fuel line that was removed from carb. If you don't have an air hose disassemble everything from the tank, including the tank pick up tube, to the carb and clean. |
05-11-2011, 09:48 PM | #10 |
Gone Wild
Join Date: Jan 2008
Location: Covington, TN
Posts: 1,942
|
Re: Help with G16 A!!!
Check the accelerator cables, if they are not working the engine may not have compression.
|