|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
09-13-2014, 08:18 PM | #1 |
Not Yet Wild
Join Date: Sep 2014
Posts: 9
|
New to Forum, G2 runs strong until it get hot
It will run down the road 1/4 mile, and turn around run not as strong, get to the house let it sit 3-5 Min and It will not run and if it does it's week and dies.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
09-13-2014, 08:26 PM | #2 |
Gone Wild
Join Date: Mar 2014
Location: Bountiful, Utah
Posts: 884
|
Re: New to Forum, G2 runs strong until it get hot
I would start by making sure the valves are adjusted to spec.
|
09-13-2014, 09:11 PM | #3 |
Not Yet Wild
Join Date: Sep 2014
Posts: 9
|
Re: New to Forum, G2 runs strong until it get hot
Thanks I will check that.
|
09-13-2014, 11:10 PM | #4 |
Vegas modded 420
Join Date: Jun 2009
Location: West MI
Posts: 15,443
|
Re: New to Forum, G2 runs strong until it get hot
Are the cooling fins full of dirt? You have to take the cowling loose to check. Could also be a coil maybe ignitor going bad when it gets hot but they usually start cutting out spark. Also check the fuel tank venting some are the cap some also have a vent on the tank. You can loosen the cap and take a spin to test. After that check all the fuel and pulse lines for cracks any leaks can cause issue though it seems more heat related.
|
09-14-2014, 08:40 AM | #5 |
Not Yet Wild
Join Date: Sep 2014
Posts: 9
|
Re: New to Forum, G2 runs strong until it get hot
Thanks, I pulled the tank cleaned it out, replaced fuel lines to clear lines so I can see fuel in lines. replaced coil, cleaned engine. I will change the Plug again today.
|
09-15-2014, 06:34 PM | #6 |
Not Yet Wild
Join Date: Sep 2014
Posts: 9
|
Re: New to Forum, G2 runs strong until it get hot
Check and found the Ignitor box is cracked and water has entered box, rust and crosion inside.
So where can I find a replacement used or new box J38-82305-20 Thanks I did find one for $263.00 but was hoping on better price. |
09-16-2014, 02:40 AM | #7 |
Searching for The Way
Join Date: Oct 2009
Location: Medina, Ohio (NEOHIO)
Posts: 11,436
|
Re: New to Forum, G2 runs strong until it get hot
You won't find much better price for a new one. Your best bet is a used piece. Post a thread in the parts section and see if anyone responds. You might want to put a picture of your part in there also.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
g1 strong then weak | Gas Yamaha | |||
'84 CC axle, how strong is it? | Bike & ATV Engine Swaps | |||
G19 strong batteries but no go | Electric Yamaha | |||
running strong | Gas EZGO | |||
Is this a strong cart? | Gas Club Car |