|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
07-01-2017, 08:35 PM | #11 |
Not Yet Wild
Join Date: Mar 2017
Location: Eastern Kansas
Posts: 34
|
Re: Starter generator barely turning
If the FNR switch is suspected, you can check the voltage drop across it by putting one voltmeter lead on the switch input terminal (from the bat), and the other lead on the output terminal going to the starter generator. I don't know what the spec would be but it should be pretty low, less than a half volt I would think. That's while cranking it over, of course.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-10-2017, 09:13 AM | #12 |
Not Yet Wild
Join Date: Nov 2013
Posts: 8
|
Re: Starter generator barely turning
I had the same problem. Starter tested good, the brushes were worn, but not all the way to the wear marks. Brushes are $12 so I went ahead and replaced them. Also cleaned up inside the starter. Works great now! It's worth the ten minutes.
|
07-26-2017, 02:15 PM | #13 |
Not Yet Wild
Join Date: Jul 2009
Location: Newport, NC
Posts: 39
|
Re: Starter generator barely turning
I just changed the brushes and that was my main problem. You can see that they were almost down to the line. They look like they still could be good enough but no.
|
07-27-2017, 08:39 AM | #14 |
Not Yet Wild
Join Date: Feb 2015
Posts: 48
|
Re: Starter generator barely turning
My A1 terminal is toasted. Trying to decide between new import or find a good repair shop. I would prefer the later, just not sure where to take it.
|
08-10-2017, 08:23 AM | #15 |
Not Yet Wild
Join Date: Feb 2015
Posts: 48
|
Re: Starter generator barely turning
Took the end of the starter generator off and the brush holder was broken where the A1 terminal is connected. I found the cap complete with brush holder, brushes and terminals on eBay for $34. I cleaned everything up, installed the new cap and the starter generator is working as it should.
|
08-10-2017, 11:18 PM | #16 |
Gone Wild
Join Date: Feb 2009
Location: Sanger, Ca.
Posts: 1,689
|
Re: Starter generator barely turning
That's great.
|
08-11-2017, 07:27 AM | #17 |
Gone Wild
Join Date: Dec 2010
Location: Woodstock,GA
Posts: 1,088
|
Re: Starter generator barely turning
Doesn't just P-ss you when you take the time and spend the money at a shop and they don't know what their are doing!!!!!
They just hooked juice to you starter and it turned, they did not do a draw test! |
08-11-2017, 09:30 AM | #18 |
Gone Wild
Join Date: Dec 2008
Location: Liberty Lake, WA
Posts: 479
|
Re: Starter generator barely turning
And all that "Certified Expert work" for $60.+ per hour.
|
08-11-2017, 03:50 PM | #19 |
Not Yet Wild
Join Date: Feb 2015
Posts: 48
|
Re: Starter generator barely turning
I should know better than to take anything to that shop. They are the largest used golf cart distributor in the world. Pretty well known place in Georgia. I guess I go there because they have a ton of parts but they don't have mechanics just parts replacers.
|
08-12-2017, 08:55 AM | #20 |
Gone Wild
Join Date: Dec 2010
Location: Woodstock,GA
Posts: 1,088
|
Re: Starter generator barely turning
you must be over on the east coast? I have seen a large cart place off 95 while passing thru to Jax.
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Starter Not Turning: Solenoid Click Only | Gas Harley Davidson | |||
Starter Not Turning Over | Gas EZGO | |||
96 club car ds starter barely cranks | Gas Club Car | |||
88 ezgo gas starter/generator stuck in starter mode | Gas EZGO | |||
Slow turning starter | Gas EZGO |