07-08-2016, 10:36 AM | #1 |
Not Yet Wild
Join Date: Jul 2016
Posts: 8
|
MCI cam seized
2011 mci cam seized, is there anyway of checking the engine oil system to insure the head is getting the proper amount of oil, looks as if the clutch side of the cam was not getting lubricated as it should have,dont want to replace the head and have the same happen again
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-15-2016, 03:51 AM | #2 |
Not Yet Wild
Join Date: Jun 2015
Posts: 1
|
Re: MCI cam seized
bump.... curious of this myself.... Thanks
|
07-19-2016, 10:01 PM | #3 |
Getting Wild
Join Date: Oct 2010
Location: Michigan
Posts: 117
|
I have seen this a few times, when ezgo came out with the "mci" engine they cheapened them up buy removing the oil galley that ran across the valve cover and removed some of the cooling fins they also casted the exhaust manifold and head as one piece.
So now instead of the oil spraying evenly across the entire valve train and cam shaft through multiple holes in the valve cover the oil just squirts or sprays from one side across the valve train which in my opinion is not a good set up. Most likely the motor was a little low on oil. Causing the cam shaft to seize up from a lack of oil. If you want to check to see if it's pumping oil just remove the valve cover and crank the engine over but put a rag or your hand over the valve train area because if it's pumping oil you'll get a bath. Hope this helps you out |
07-21-2016, 12:56 PM | #4 |
Not Yet Wild
Join Date: Jul 2016
Posts: 8
|
Re: MCI cam seized
Thanks for the info bud, i did check to see if it was getting oil by doing just what you said,and it is. i agree with you in the fact that by doing away with the oil passage through the valve cover was simply stupid,why change something if it works just fine. thanks again for your reply
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Seized Engine | Gas EZGO | |||
Tie rod seized | Electric Club Car | |||
seized motor? | Gas Yamaha | |||
unsure seized or not. | Gas EZGO | |||
Engine help (seized) G9 | Gas Yamaha |