|
06-03-2012, 09:42 AM
|
#1 |
|
Not Yet Wild
Join Date: Jun 2012
Posts: 6
|
ez-go 2 stroke
Hello I've just joined. I'd like some help My cart just stopped running Ive got spark It will turn over on starter fluid compression is good fuel lines clear any suggestions??
|
|
|
 Today
|
|
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
|
06-03-2012, 09:58 AM
|
#2 |
|
Hammer Down !!!!
Join Date: Jun 2010
Location: Lake Geneva, WI
Posts: 2,681
|
Re: ez-go 2 stroke
Welcome to the forum !!! Sounds like a fuel delivery issue at first glance so let's try a couple of relatively simple things first:
1: Pull the fuel line from the carb and turn the engine over, you should have a healthy pulse of fuel spurting from the line. If so, we just eliminated the fuel delivery up to the pump, which leaves us the next step ... 2: remove the throttle, choke and governor cables as well as unhooking the fuel line and air intake. There are 2 10mm nuts that hold the carb onto the intake, remove them (being careful not to damage the gasket). Now that you have the carb in your hands, follow this illustration to disassemble it and make SURE to pay special attention to the jets I have circled - they need to be removed and thoroughly cleaned using a can of pressurized carb cleaner. Alos, while you're in there, make sure to thoroughly clean out the needle valve seat (also circled) and gey any gunk, etc out of the float bowl. Now, do the whole thing backwards until you have the carb reinstalled as it was, try it again and hopefully you'll be off and running !!!  |
|
|
|
|
06-03-2012, 10:07 AM
|
#3 |
|
Not Yet Wild
Join Date: Jun 2012
Posts: 6
|
Re: ez-go 2 stroke
Thank you brew! I'll giver a go after work and let u know
|
|
|
|
|
06-03-2012, 08:03 PM
|
#4 |
|
Not Yet Wild
Join Date: Jun 2012
Posts: 6
|
Re: ez-go 2 stroke
Thank you soo much Mr Brew you are officially my go to guy and hero!!
|
|
|
|
|
06-03-2012, 08:07 PM
|
#5 |
|
Gone Wild
Join Date: May 2011
Location: Michigan
Posts: 271
|
Re: ez-go 2 stroke
mine to...................
|
|
|
|
|
06-03-2012, 08:42 PM
|
#6 |
|
Hammer Down !!!!
Join Date: Jun 2010
Location: Lake Geneva, WI
Posts: 2,681
|
Re: ez-go 2 stroke
*wipes a tear from his eye*
So, I'm hoping the kudos means it worked ?!?!?! |
|
|
|
|
06-05-2012, 11:33 AM
|
#7 |
|
Not Yet Wild
Join Date: Jun 2012
Posts: 6
|
Re: ez-go 2 stroke
Yes It did work, However its still sluggish goin up hills,
 |
|
|
|
|
06-05-2012, 03:14 PM
|
#8 | |
|
Never really finished
Join Date: Jun 2010
Location: Georgia
Posts: 1,102
|
Re: ez-go 2 stroke
Quote:
 |
|
|
|
|
|
06-05-2012, 04:59 PM
|
#9 |
|
Hammer Down !!!!
Join Date: Jun 2010
Location: Lake Geneva, WI
Posts: 2,681
|
Re: ez-go 2 stroke
first, define "sluggish" - is it starting up the hill good then slowly bogging down and not changing RPM's to "power up" ??? There are so many things that could lead to loss of power under load that you're going to have to be a little more descriptive so we can try and help you without a lot of unneccessary troubleshooting ...
|
|
|
|
|
07-01-2012, 01:36 PM
|
#10 |
|
Not Yet Wild
Join Date: Jun 2012
Posts: 6
|
Re: ez-go 2 stroke
Well its been awhile I know. but I did find out it only sluggish going forward,in reverse it rocks!! Whay gives??
|
|
|
|
 |
| Tags |
| 1991 marathon i believe |
|
||||||
|
|
Similar Threads
|
||||
| Thread | Forum | |||
| 2 Stroke into 4 stroke conversion | Big Block Talk! | |||
| 91 GXT 800. 2 stroke to 4 stroke swap..HELP | Big Block Talk! | |||
| 91 GXT 2 stroke to 4 stroke swap. HELP! | Members Rides | |||
| 88 ezgo 2 stroke convert to 4 stroke | Gas EZGO | |||
| can i use 2 stroke ezgo clutch on 4 stroke | Big Block Talk! | |||
Linear Mode
