Charger Question

[subby44]

My Uncle has a 2004 Ezgo.. He is having trouble with the Charger. When he plugs the charger into the cart he gets 2 red blinks on the charger. does this mean there is a voltage fault? or could the charger be bad? here is a pic of the charger. TIA.. any ideas on a fix would help...

[JohnnieB]

Two red blinks is battery fault.

What is the Battery pack voltage?

I found the fault codes:
LED OPERATION CODES:
SHORT GREEN FLASH = less than 80% charged
LONG GREEN FLASH = more than 80% charged
SOLID GREEN = 100% charged
RED FLASH = fault code
LED FAULT CODES:
RED FLASH: Light turns on briefly, but does not
flash after that - check for valid AC voltage.
ONE RED FLASH: One flash, a pause and then
again one flash and a pause - Charge Enable
Fault: poor contact in the DC connector or dirty
contacts or Battery Temperature Fault: battery
temperature is greater than 122° F (50° C) or less
than 14° F (-10° C).
TWO RED FLASHES: Two flashes, a pause and
then again two flashes and a pause - Battery Voltage
Fault: Battery pack is less than 36.0 Volts or
more than 67.2 Volts. Battery pack is too discharged
or over charged for the charger to work.
THREE RED FLASHES: Three flashes, a pause
and then again three flashes and a pause - Battery
Charge Time-out: Charge time exceeded 24
hours. This may indicate a problem with the battery
pack or that the charger output current was
severely reduced due to high ambient temperatures.
FOUR RED FLASHES: Four flashes, a pause and
then again four flashes and a pause - Battery
Fault: Charge time exceeded. This indicates a
problem with the battery pack voltage not reaching
the required nominal level within the maximum
time allowed.
SIX RED FLASHES: Six flashes, a pause and
then again six flashes and a pause - Charger
Fault: An internal fault has been detected. If this
fault is displayed again after unplugging the
charger’s DC power cord and plugging it back in,
the charger must be taken to a qualified service
center.

[Sandra Hull]

What does red blinking light (fault) on the charger mean?

Originally Posted by Sandra Hull

What does red blinking light (fault) on the charger mean?

if you read the above post it explains the codes