|
Electric Yamaha Electric Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
10-08-2020, 11:15 AM | #1 |
Gone Wild
Join Date: Jul 2019
Posts: 356
|
g16 Has no torque
I have a 2000 G16 that I posted about earlier. The cart has all new batteries, and a D D 20% torque motor. I have 38.5 in the batteries, all cables are good and clean. The cart will run 16-18 with no problem and gets there as it should. The problem is with 2 people going up a Florida hill one has to get off and push. When loading on a trailer if you stop anywhere in the process you have to back up and get a running start???
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
10-08-2020, 11:57 AM | #2 |
Gone Wild
Join Date: Jul 2019
Posts: 356
|
Re: g16 Has no torque
yes confirmed all batteries are good under load. Total pack reading when "stalled" 35.2 and the controller makes a squealing/hissing type noise
|
10-10-2020, 02:49 PM | #3 |
Gone Wild
Join Date: Jul 2019
Posts: 356
|
Re: g16 Has no torque
ok so got my new sr controller today. installed it as directed. When you push the pedal the response is very erratic. I plugged the controller into the laptop and in monitoring mode you can see the throttle percentages going all over the place. Normally I would think the throttle would be bad, but this one worked fine with the stock controller I had all ranges of speed and it was smooth
The directions say to cut and cap off the brown wire from the foot switch, but I thought I read somewhere something else about the brown wire. |
10-14-2020, 11:09 AM | #4 |
Gone Wild
Join Date: Jul 2019
Posts: 356
|
Re: g16 Has no torque
Got everything worked out. Wired as per instructions with my glasses this time all is good. Cart works as it should.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Torque i need torque!!!2001 DS | Electric Club Car | |||
New D&D Torque Motor (4:1) - Not Seeing 40% Torque | Electric EZGO | |||
need torque LBS and torque pattern for 2000 club car ds gas transaxle | Gas Club Car | |||
D&D Speed&Torque vs. D&D High Torque | Electric EZGO | |||
Electric Torque vs Gas Torque | Electric Club Car |