lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Yamaha
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles



Post New Thread  Reply
 
Thread Tools Display Modes
Old 12-08-2010, 08:22 PM   #1
nitro1
Gone Wild
 
nitro1's Avatar
Yamaha
 
Join Date: May 2010
Location: OHIO
Posts: 1,229
Default Secondary clutch question

hey guys when i shift to reverse and forward it take a few seconds to kick in gear and some times makes a noise of some sort.......why wont it shift when i want to go forward/reverse?
nitro1 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 12-08-2010, 10:03 PM   #2
Mike Mac
G8 Specialist
Yamaha
 
Join Date: Jun 2009
Location: Phoenix
Posts: 7,793
Default Re: Secondary clutch question

Nitro, I would start with maintenance. Check to see that there is oil in rear end, if its not clean change it. Make sure its at the proper level. Then grease clutches, and make sure they are articulating. Make sure motor mounts are good (holding the motor in place under load). Also Lube shifter cables.
Mike Mac is offline   Reply With Quote
Old 12-08-2010, 10:16 PM   #3
nitro1
Gone Wild
 
nitro1's Avatar
Yamaha
 
Join Date: May 2010
Location: OHIO
Posts: 1,229
Default Re: Secondary clutch question

i changed the rear end oil about a month ago so that should be good, ill try the other things u said above

for the rear end i took the pumpkin cover off and filled it till it came out is that correct way, im pretty sure that's how
nitro1 is offline   Reply With Quote
Old 12-09-2010, 04:47 PM   #4
Mike Mac
G8 Specialist
Yamaha
 
Join Date: Jun 2009
Location: Phoenix
Posts: 7,793
Default Re: Secondary clutch question

Ya Nitro, I'm pretty sure that is correct! I don't have that rear end, but ya. Maybe also, have somebody move the shifter back and forth, while you watch the cables and how they move the shifter arm on the tranny. Maybe you will be able to tell if the cables are moving the arm far enough. Also if you are in cold climate, Smallblock says that sometimes the cables get ice/water in them and freeze.
Good luck Mike
Mike Mac is offline   Reply With Quote
Old 12-09-2010, 09:31 PM   #5
Mike Mac
G8 Specialist
Yamaha
 
Join Date: Jun 2009
Location: Phoenix
Posts: 7,793
Default Re: Secondary clutch question

Ya know, I shift my body weight when I shift the car to either direction. I throw my body weight forward to move the car an inch or so,so the teeth in the tranny mesh instead of sitting beside each other. If you can vision what I mean. I do it now and I don't even think about it when I'm doing it.
Mike Mac is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Yamaha


Thread Tools
Display Modes


Similar Threads
Thread Forum
wtb:secondary clutch Golf Carts and Parts
Secondary Clutch Gas Yamaha
G1 Secondary Clutch Gas Yamaha
G16 Secondary clutch Gas Yamaha
Need a secondary clutch Golf Carts and Parts


All times are GMT -5. The time now is 09:53 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2021, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. 2006-2017 Buggiesgonewild.com. All rights reserved.