|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
04-19-2011, 08:06 PM | #1 |
REAL MEN GET EM DIRTY
Join Date: Jun 2009
Location: rincon , ga.
Posts: 3,646
|
gas coming out of carb after some mods
lets see if i can explain whats going on and make sense of it. i changed the fuel pump, the fuel lines, the vacuum line, and the rear clutch with a 28deg. i also adjusted the gov. ran fine a day, then it started sputtering, popping, and hesitating. i pulled the air filter out and saw fuel standing in the carb with a little in the air box. i was playing in the ditch across from my house a little bit ago and it started sputtering really bad and would not come out the ditch without a rolling start. but on flat ground it will run like a bat out of hell. i did check the valves a few weeks ago and it ran fine until i changed the pump and all.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-19-2011, 08:43 PM | #2 |
Redneck in Southside
Join Date: Jul 2010
Location: Spencer, Virginia
Posts: 1,252
|
Re: gas coming out of carb after some mods
maybe picked up some trash in carb? just a thought
|
04-19-2011, 08:47 PM | #3 |
REAL MEN GET EM DIRTY
Join Date: Jun 2009
Location: rincon , ga.
Posts: 3,646
|
Re: gas coming out of carb after some mods
i did think about that, i was thinking about pulling the carb and spraying it down real good.
|
04-24-2011, 04:50 PM | #4 |
REAL MEN GET EM DIRTY
Join Date: Jun 2009
Location: rincon , ga.
Posts: 3,646
|
Re: gas coming out of carb after some mods
well i did a tune up on the cart, new plugs and oil. i checked the valves and they were fine. to it out for a spin and it seems to be better than it was. it ran really good for a while then started acting up again.
|
04-24-2011, 05:10 PM | #5 |
Gone Wild
Join Date: Feb 2011
Location: california
Posts: 151
|
Re: gas coming out of carb after some mods
If the old pump still works, put it back and find out if there is no improvement. Is your new pump an OEM?
|
04-25-2011, 07:58 AM | #6 |
REAL MEN GET EM DIRTY
Join Date: Jun 2009
Location: rincon , ga.
Posts: 3,646
|
Re: gas coming out of carb after some mods
The new pump is oem. Ill try and find it and give it a try
|
04-25-2011, 11:49 AM | #7 |
Not your usual outlaw
Join Date: Oct 2008
Location: Near Lake Geneva, WI
Posts: 20,054
|
Re: gas coming out of carb after some mods
|
04-25-2011, 10:58 PM | #8 |
REAL MEN GET EM DIRTY
Join Date: Jun 2009
Location: rincon , ga.
Posts: 3,646
|
Re: gas coming out of carb after some mods
i was doing some thinking today i put the new pump in after the new clutch thinking the original pump was going out. the new pump didnt change anything. now i have noticed that the engine is running lower rpms. could it be possible that the clutch would effect the engine rpms via the governor. i havent had time to put the original clutch back in to see if it changes anything. i do have the 350 and dont really need the 28deg clutch, just though it would help with hill climbing.
|
04-27-2011, 09:46 PM | #9 |
REAL MEN GET EM DIRTY
Join Date: Jun 2009
Location: rincon , ga.
Posts: 3,646
|
Re: gas coming out of carb after some mods
ok, i put the original pump and clutch back on today. nothing has changed. and now im blowing some some at first start up. i also noticed what sounds like a rod knocking when it first starts up. the last time i heard that noise was with the original motor that was gone. i think i was told that the bottom end was busted.
|
04-27-2011, 10:18 PM | #10 |
Not Yet Wild
Join Date: Mar 2011
Location: San Diego
Posts: 7
|
Re: gas coming out of carb after some mods
If you haven't already done so, Pull the carb and check to see if the needle and seat are ok. I've had this happen before after switching fuel pumps, the new pump was pushing out a lot more pressure(possibly a bad pump) and forced the needle off the retainer on the float, causing this type of flooding situation.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Tire keeps coming off rim | Gas EZGO | |||
Parts are coming | Members Rides | |||
91 2 Cycle Carb Missing Carb Screw | Gas EZGO |