|
Electric Yamaha Electric Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
08-13-2017, 03:58 PM | #1 |
Not Yet Wild
Join Date: Sep 2015
Location: St-Albans Vermont
Posts: 30
|
YDRE Key on and no click from solenoid
Troubleshooting for my sister-in-law.She has a 2010 YDRE :
Batteries are fully charged and I cleaned all terminals. Key on and no click from solenoid. No click when switching between "tow" and "run". Reverse buzzer does not sound when switched to reverse or at all for that matter. No click when pushing the cart back and forth manually in "run". There is 50.1 volts across the large terminals of the solenoid. Any advice on what I can do to figure this out would be greatly appreciated.Thanks. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-14-2017, 06:00 AM | #2 |
Not Yet Wild
Join Date: Sep 2015
Location: St-Albans Vermont
Posts: 30
|
Re: YDRE Key on and no click from solenoid
I am a plumber by trade so my electrical knowledge is limited.
Sent from my iPhone using Tapatalk |
08-14-2017, 08:14 AM | #3 |
Gone Wild
Join Date: Sep 2014
Location: Orlando, FL
Posts: 1,308
|
Re: YDRE Key on and no click from solenoid
Check the 3A fuse located left of the controller in the pic attached. You can access it from under the seat driver side in the wire loom on the vertical seat support behind the batteries. The 3A fuse is shown in the middle left of the drawing attached.
|
08-15-2017, 08:50 AM | #4 |
Not Yet Wild
Join Date: Sep 2015
Location: St-Albans Vermont
Posts: 30
|
Re: YDRE Key on and no click from solenoid
Thanks PingEye3.Will do.I appreciate your help.
|
08-18-2017, 05:50 PM | #5 |
Not Yet Wild
Join Date: Sep 2015
Location: St-Albans Vermont
Posts: 30
|
Re: YDRE Key on and no click from solenoid
That fuse checks out okay.Is there some kind of guide available that can assist me?
|
08-18-2017, 07:27 PM | #6 | |
Not Yet Wild
Join Date: Aug 2017
Posts: 5
|
Re: YDRE Key on and no click from solenoid
Quote:
YDRA, YDRE GOLF CAR SERVICE MANUAL I have a problem similar to yours and have a new solenoid on order. My post below is the one asking where is the fuse. Like you my fuse looks ok. The manual has trouble shooting section. Some of the contents of troubleshooting TROUBLESHOOTING 9-2 YDRA/E Service Manual Car Will Not Run at Rated Speed .................................................. ..... 9-20 Car Will Not Operate in Either Direction - Solenoid Does Not Click.... 9-21 Car Will Not Operate in Either Direction - Solenoid Does Click .......... 9-22 No Regenerative Braking or Rollaway Protection ............................... 9-24 — Z-2 Diagnostic Tester — YDRE Electrical Troubleshooting Flow Chart ..................................... 9-25 Z-2 Harness Connections .................................................. ................. 9-26 Z-2 Tester............................................ .......................................... 9-26 Z-2 Tester Harness Adapter........................................... ............... 9-26 Preliminary Checks and Guidelines .............................................. 9-26 Operating Instructions .................................................. ....................... 9-27 Z-2 Tester Failure Chart .................................................. .................... 9-28 — Genius Diagnostic System — Introduction .................................................. ....................................... 9-30 Genius Diagnostic System............................................ ...................... 9-30 Personal Digital Assistant (PDA)............................................. ...... 9-30 Transmitter Unit.............................................. ............................... 9-30 Software Installation...................................... ................................ 9-30 Diagnostic Mode .................................................. ............................... 9-31 Connecting the PDA............................................... ....................... 9-31 PDA Operation Procedures........................................ ................... 9-31 Data Screen .................................................. ................................ 9-32 Read Tab............................................... .................................. 9-33 Set Car # Tab .................................................. ........................ 9-34 Faults Screen .................................................. .............................. 9-35 Faults............................................ ........................................... 9-35 Help .................................................. ....................................... 9-36 About Application .................................................. .................. 9-37 Read Tab............................................... .................................. 9-37 Erase Tab............................................... ................................. 9-37 Troubleshooting Using Genius............................................ ................ 9-39 Golf Car Programming Mode .................................................. ............ 9-46 PDA Operation Procedures........................................ ................... 9-46 |
|
11-03-2020, 08:46 PM | #7 |
Not Yet Wild
Join Date: Nov 2020
Posts: 1
|
Re: YDRE Key on and no click from solenoid
do you have a copy of the flow chart?
|
11-06-2020, 08:20 AM | #8 |
Gone Wild
Join Date: May 2012
Location: Rio Verde, Az
Posts: 7,123
|
Re: YDRE Key on and no click from solenoid
Yamaha controllers fail often. So do the solenoids. It is going to be one of those. Are you sure you checked the correct fuse? It's tucked in the driver side in the back and it's not that easy to find.
|
11-06-2020, 07:54 PM | #9 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: YDRE Key on and no click from solenoid
I see very few solenoid failures, but a lot of controller failures, and the fuse you should find should be 3 amp (assuming you have a stock controller).
|
09-19-2021, 01:11 PM | #10 |
Not Yet Wild
Join Date: Jun 2021
Location: Maryland
Posts: 8
|
Re: YDRE Key on and no click from solenoid
I have the same problem. Did you ever find a solution?
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
2012 ydre, solenoid clicks but no go? | Electric Yamaha | |||
09 YDRE strange selonoid click occurance? | Electric Yamaha | |||
2009 YDRE solenoid takes long time to drop out | Electric Yamaha | |||
YDRE heavy duty solenoid problem | Electric Yamaha | |||
03 48v cc solenoid will not click | Electric Club Car |