01-10-2012, 07:55 PM | #1 |
Not Yet Wild
Join Date: Jan 2012
Posts: 6
|
Club Car 2005 Gas
I have checked everything and even have a new battery -- but it will not recharge the battery -- runs well when charged and then it dies so it does not recharge -- tried everything. Have any suggestions on what to check??
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
01-10-2012, 08:09 PM | #2 |
Gone Wild
Join Date: Jan 2007
Location: La Porte Indiana
Posts: 1,392
|
Re: Club Car 2005 Gas
what is the battery voltage at rest and while the engine is running?
|
01-10-2012, 08:30 PM | #3 |
Not Yet Wild
Join Date: Jan 2012
Posts: 6
|
Re: Club Car 2005 Gas
the battery is not charging -- no current going back to the battery -- it puts up 11 to 12 volts when it is running and then it does not re-charge -- it is a brand new battery
|
01-10-2012, 08:34 PM | #4 |
Gone Wild
Join Date: Jan 2007
Location: La Porte Indiana
Posts: 1,392
|
Re: Club Car 2005 Gas
do a search on here. there is a test to check out the generator. i beleive you pull the yellow wire and ground it. that full fields the gennerator and puts about 15 volts to the battery. if that happens you have a bad voltage regulator, or bad wiring going from the generator to the voltage regulator to the battery. or somewhere in between.
hope that helps, Aaron |
01-10-2012, 09:04 PM | #5 |
Not Yet Wild
Join Date: Jan 2012
Posts: 6
|
Re: Club Car 2005 Gas
thanks Aaron will try that tomorrow -- sure is puzzling
|
01-10-2012, 09:06 PM | #6 | |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: Club Car 2005 Gas
Quote:
follow Aarons advice....if you have a digital voltage meter put the probes on proper battery terminals and start and rev cart up if voltage dosn,t rise to 13.9 to 15.7 or inbetween the V.R. more than likely is bad.................. |
|
01-10-2012, 09:20 PM | #7 |
Not Yet Wild
Join Date: Jan 2012
Posts: 6
|
Re: Club Car 2005 Gas
thanks -- have something to try tomorrow -- thanks so much will keep you posted
|
01-11-2012, 10:05 AM | #8 |
Not Yet Wild
Join Date: Jan 2012
Posts: 6
|
Re: Club Car 2005 Gas
looked everywhere -- where do you find the serial number on this club car -- thanks for you help
|
01-11-2012, 10:49 AM | #9 |
Gone Wild
Join Date: Jan 2012
Posts: 359
|
Re: Club Car 2005 Gas
|
01-11-2012, 11:36 AM | #10 | |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: Club Car 2005 Gas
Quote:
yes lower dash about center, if its only putting out 12 volts when running theres a real good chance the voltage regulater went bad..........the starter/generator while they do go bad its very rare, i,m not sure what all or how you tested anything but if it were me i,d start with the VR............................. |
|
|
|
Similar Threads | ||||
Thread | Forum | |||
My 2005 Club Car | Members Rides | |||
2005 club car (gas) | Gas Club Car | |||
2005 Club Car 272 | Gas Club Car | |||
2005 club car | Gas Club Car |