lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car
Gas Club Car Gas DS, and Precedent golf cars



Post New Thread  Reply
 
Thread Tools Display Modes
Old 04-23-2021, 05:26 PM   #1
mikes3028
Not Yet Wild
 
Join Date: Oct 2010
Posts: 23
Default 1996 Carryall FE290

Hey guys just had my engine rebuilt and want to replace all the fuel lines. I have the part numbers but can't get anything to come up. What are ya'll replacing your fuel lines with? Thanks for any replies.
mikes3028 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 04-23-2021, 05:31 PM   #2
meimk
Gone Wild
 
meimk's Avatar
Club Car
 
Join Date: Jun 2011
Location: Northern Indiana
Posts: 1,994
Default Re: 1996 Carryall FE290

1/4 inch rubber fuel line hose, cut to whatever length needed.
meimk is offline   Reply With Quote
Old 04-24-2021, 03:49 PM   #3
mikes3028
Not Yet Wild
 
Join Date: Oct 2010
Posts: 23
Default Re: 1996 Carryall FE290

ok. thanks. that's what I thought I could use but wanted to make sure. thanks for the reply.
mikes3028 is offline   Reply With Quote
Old 04-24-2021, 06:55 PM   #4
CP241
Eats dirt.
 
CP241's Avatar
Club Car
 
Join Date: Apr 2018
Location: Michigan
Posts: 5,874
Default Re: 1996 Carryall FE290

Personal preference but I like the clear blue fuel line. You can see it flowing through and in the event you need to diagnose fuel issues it can be helpful.
CP241 is offline   Reply With Quote
Old 04-26-2021, 10:16 AM   #5
mikes3028
Not Yet Wild
 
Join Date: Oct 2010
Posts: 23
Default Re: 1996 Carryall FE290

yes sir. my old lines are clear. well, yellow now. where do you get that clear blue line at?
mikes3028 is offline   Reply With Quote
Old 04-26-2021, 10:24 AM   #6
CP241
Eats dirt.
 
CP241's Avatar
Club Car
 
Join Date: Apr 2018
Location: Michigan
Posts: 5,874
Default Re: 1996 Carryall FE290

This is what Iíve used in the past. It forms to the fittings on the fuel filters and stuff *very* well. Once itís been on there a week or so youíll probably have to cut it off if you want to remove it. I like the seal https://www.ebay.com/itm/Fuel-Line-1....m46890.l49286
CP241 is offline   Reply With Quote
Old 04-26-2021, 05:23 PM   #7
mikes3028
Not Yet Wild
 
Join Date: Oct 2010
Posts: 23
Default Re: 1996 Carryall FE290

thanks I appreciate that info. I will definitely look into it. I also like the cline fuel lines also, thanks again
mikes3028 is offline   Reply With Quote
Old 04-27-2021, 02:21 PM   #8
mikes3028
Not Yet Wild
 
Join Date: Oct 2010
Posts: 23
Default Re: 1996 Carryall FE290

should have been clear lines in case someone was wondering
mikes3028 is offline   Reply With Quote
Old 04-29-2021, 08:17 AM   #9
nwocart
Gone Wild
Club Car
 
Join Date: Jun 2016
Posts: 493
Default Re: 1996 Carryall FE290

This is the best clear blue fuel line that I've found:
Stens brand
https://www.ebay.com/itm/28313520689...8AAOSwJ7dbEt88

I've used the cheaper clear blue stuff from rural king and it gets hard after it experiences a little heat. The stens stuff has held up good on my fe290. Its not the cheapest, but its the best quality. It can be removed, while the cheaper stuff usually gets hard and you have to cut it like CP said above me


Pro tip: get the size I linked (3/16" ID) and use needle nose pliers to stretch the end right before you put it on the hose barb. it will shrink back down and remain tight enough that you dont need hose clamps, and makes for easy removable. Been doing this on snowmobiles, atvs, and carts for years.


Also don't forget new fuel filters while youre doing the lines!
nwocart is offline   Reply With Quote
Old 05-03-2021, 10:23 AM   #10
mikes3028
Not Yet Wild
 
Join Date: Oct 2010
Posts: 23
Default Re: 1996 Carryall FE290

alright, got everything back together. got some clear fuel lines and all new filters. put some oil in the motor and now it runs so smooth. glad to have it back in working order. it gets used everyday. thanks to everyone that has replied to my questions. shout out to vic auito in Marietta ga for the rebuild.
mikes3028 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
05 carryall 2 with a fe290? Gas Club Car
1996 Club Car FE290 Golf Carts and Parts
1996 club Car FE290 compression? Gas Club Car
1996 CC FE290 cuts out on take off Gas Club Car
Fe290 Valve Springs 1996 Club Car Gas Club Car


All times are GMT -5. The time now is 10:56 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2021, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.