|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
05-07-2010, 10:03 AM | #1 |
Getting Wild
Join Date: Mar 2009
Location: Texas Baby!
Posts: 141
|
Massive Steering Wheel Vibration
On my 2004 CC IQ. What could be causing this? I have a 6" lift and 23's.
It vibrated when I bought it, and I took it to a guy who adjusted tire pressure and camber and that seemed to help. Now it's worse than ever before. I dont ride it very often, could it be flat spots on the tires from sitting? Help! Thanks |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
05-07-2010, 12:31 PM | #2 |
Gone Wild
Join Date: Mar 2009
Location: South Texas
Posts: 2,391
|
Re: Massive Steering Wheel Vibration
By vibration I assume you are talking about tire bounce ( like auto tires when unbalanced ) that occurs when you are going down road and that gets worse as speed goes up, or are you talking about slight twisting back and forth motion of steering wheel while driving? The later should have been solved by wheel alignment that you had done.
New tires are being shipped some times come all bent around each other to cut down on space and this can cause tire unbalanced condition. It makes the tire out of round that you can check by jacking up each wheel and placing something solid close to tread and rotate tire to see. Warming most tires that have sat for periods of time will have a flat spot where tire rested on ground, so take cart out and warm tires up good before doing this test. In south Texas this should only take a few minutes. Then check in the same manner the wheel bead on side wall for out of round as some after market wheels are not very well machined from manufacturer. Be sure and check wheel lugs for proper alignment as I have seen some with wheel holes not drilled correctly and lugs dont seat down in indentations properly. Be assured you are not alone with this problem as many just put up with a dangerous condition that shortens the suspension life as well as what you yourself sit on and causes you to loose some steering control. |
05-07-2010, 12:53 PM | #3 |
Getting Wild
Join Date: Mar 2009
Location: Texas Baby!
Posts: 141
|
Re: Massive Steering Wheel Vibration
Thanks Old Mec. When I bought my tire and wheel package off ebay, one of the tires was very obviously out of round. I contacted the seller and they sent me a new wheel & tires, no questions asked. I wonder if maybe these others are slightly out of round too, and not obvious to the naked eye like the first one.
The condition on my cart definately gets worse, the faster I go. When I get up tp around 20 mph it's shaking pretty voilently, even the steering column. |
05-07-2010, 12:57 PM | #4 |
Not your usual outlaw
Join Date: Oct 2008
Location: Near Lake Geneva, WI
Posts: 20,054
|
Re: Massive Steering Wheel Vibration
SKM what kind of tires? Saharas?
|
05-07-2010, 01:01 PM | #5 |
Gone Wild
Join Date: Mar 2009
Location: South Texas
Posts: 2,391
|
Re: Massive Steering Wheel Vibration
If you find a wheel or tire out of round or you are suppitious of one wheel you might try moving it to rear of cart where it doesnt effect steering so much. Rear wheel balance will be felt more in the back of seat than in steering wheel and floor.
As I said before drive cart and warm tires up good several times and maybe that will help stop so much vibration. Around here carts sit for whole summer ( WINTER TEXANS )in the heat and when first used in fall many that dont jack them up and block the tires off ground are almost impossible to drive at first? |
05-07-2010, 01:03 PM | #6 |
Getting Wild
Join Date: Mar 2009
Location: Texas Baby!
Posts: 141
|
Re: Massive Steering Wheel Vibration
Carlisle All-Trail's on ITP SS112 rims
|
05-07-2010, 01:12 PM | #7 |
Not your usual outlaw
Join Date: Oct 2008
Location: Near Lake Geneva, WI
Posts: 20,054
|
Re: Massive Steering Wheel Vibration
I've had that problem with Sahara 22's on 8" wheels. The tires were actually out of round.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
steering wheel | Gas Club Car | |||
steering wheel | Golf Carts and Parts | |||
'91 3-Wheel Marathon High Speed Vibration | Electric EZGO | |||
Alignment of Steering Wheel Only - Wheel Base Straight | Gas Yamaha | |||
Cant get steering wheel off? | Electric Yamaha |