|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
08-11-2020, 06:59 AM | #11 | |
Not Yet Wild
Join Date: May 2020
Posts: 22
|
Re: 2015 RXV wont move
Quote:
👍🏼👍🏼 Thanks! |
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-11-2020, 07:13 AM | #12 |
Gone Wild
Join Date: Jun 2010
Location: Georgia
Posts: 470
|
Re: 2015 RXV wont move
loose connections on main batteries or any batteries? maybe the plug under cup holder got wet, have you washed it or anything lately?
|
08-11-2020, 08:18 AM | #13 |
Not Yet Wild
Join Date: May 2020
Posts: 22
|
Re: 2015 RXV wont move
It was stripped down to the frame with a motor/differential the only thing left in place, power washed, then reassembled to the point of body parts. The entire harness and controller was removed in one piece and set aside after disconnecting from motor/brake. Bagged the motor before power washing and didn’t notice anything wet when I unbagged it. It also sat for 3 days after the wash before I put anything back together.
Already double checked all connections, plugs, etc. Checked fuse, blue wire at charger, and just about everything else I can find recommended on this and other forums. Despite being brand new, I even took individual battery readings last night, idle and with key on...all 12.8 or so in both states. I think all I can do at this point is start swapping parts out once they arrive. The biggest baffler to me is the fact that it releases and can be pushed around if I use the reset instructions/plug swap technique under the tow/run switch. And then “fails” again when I put the plugs back to 1-2 and 3-4. |
08-11-2020, 08:25 AM | #14 |
Not Yet Wild
Join Date: Aug 2020
Posts: 22
|
Re: 2015 RXV wont move
In my experience these symptoms are usually a solenoid that engages but won't hold. When you turn on the cart listen carefully; are you getting one click or two out of the solenoid? One click means it's holding, two means it isn't. If you have a handheld to troubleshoot on the controller this issue will show up as a "Main Contactor did not close" fault.
|
08-12-2020, 08:19 AM | #15 | |
Gone Wild
Join Date: Sep 2014
Location: Orlando, FL
Posts: 1,308
|
Re: 2015 RXV wont move
Quote:
|
|
08-12-2020, 08:24 AM | #16 | |
Gone Wild
Join Date: Sep 2014
Location: Orlando, FL
Posts: 1,308
|
Re: 2015 RXV wont move
Quote:
When you bypass with the plug swap, it puts pack voltage on the brake to release it. So, if the if the brake doesn't release with the KS 'on' OR when you put it in tow and KS in fwd then the voltage on the load side of the solenoid is most likely too low to release the brake. IMHO cgtech will correct me if I am wrong on this. |
|
08-12-2020, 11:13 AM | #17 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: 2015 RXV wont move
Or it could be that the controller doesnt see fit to unlock the brake, like it would do if it thought the charger were plugged in. And, when in Run, key on, the brake doesnt unlock when you turn the key on, it unlocks when you press the gas.
|
08-12-2020, 01:56 PM | #18 |
Not Yet Wild
Join Date: May 2020
Posts: 22
|
Re: 2015 RXV wont move
Sorry, guys. I got busy reading, ordering and doing other parts of the cart.
So using B- point for contact gives me 50.8 across anything I can check; pack, both sides of solenoid, etc. etc. Again, thanks for the correction on that. Based on the “two clicks” from the solenoid comment earlier, I’m thinking that’s the problem. New one gets here late today or tomorrow. I swapped the gas plunger switch this morning since it arrived separately. The new motor brake is here as well, but I want to swap the solenoid first. 👍🏼 |
08-13-2020, 05:41 AM | #19 |
Gone Wild
Join Date: Oct 2008
Location: East Texas
Posts: 586
|
Re: 2015 RXV wont move
Like GTech suggested, make sure you have all of the wires from the charge port hooked up.
|
08-13-2020, 09:09 AM | #20 | |
Not Yet Wild
Join Date: Aug 2020
Posts: 22
|
Re: 2015 RXV wont move
Quote:
|
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Wont stop beeping and wont move | Electric EZGO | |||
2015 RXV charge port short and now wont go | Electric EZGO | |||
2015 Ezgo TXT won't move | Electric EZGO | |||
Ezgo dcs solenoid clicks but wont disengage and wont move | Electric EZGO |