03-09-2017, 04:08 PM | #1 |
Not Yet Wild
Join Date: Jul 2009
Location: ZolfoSprings. Fl
Posts: 32
|
96 gas club car
Me and my son were ribe my cart at the fly wheeler show when my cart just quit running. We waited for about 10 mins and tried it and it ran. Then it quit and would not start again. I replaced fuel pump and cleaned carb but no luck. Any ideals?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
03-09-2017, 06:37 PM | #2 |
Gone Wild
Join Date: Feb 2015
Posts: 388
|
Re: 96 gas club car
Tell us about your cart?
|
03-09-2017, 06:44 PM | #3 |
Getting Wild
Join Date: Nov 2016
Location: michigan/georgia
Posts: 133
|
Re: 96 gas club car
Some 96 carts still have a chip behind the rev limiter braket wire may be loose also rev limiters go bad intermitly unhook brown ground wire by it and see if it helps
|
03-09-2017, 06:57 PM | #4 |
Not Yet Wild
Join Date: Jul 2009
Location: ZolfoSprings. Fl
Posts: 32
|
Re: 96 gas club car
I sprayed a little starting fluid in and would run the start fluid out.
|
03-09-2017, 06:58 PM | #5 |
Not Yet Wild
Join Date: Jul 2009
Location: ZolfoSprings. Fl
Posts: 32
|
Re: 96 gas club car
It has the 290FE engine.
|
03-10-2017, 09:57 AM | #6 |
Not Yet Wild
Join Date: Mar 2017
Posts: 25
|
Re: 96 gas club car
I had this issue a few months ago. It would only run when I used my hand to cover the air intake pipe to regulate the air. I cleaned the carburetor twice and replace the fuel filter. That fixed the issue.
Sent from my iPhone using Tapatalk |
03-10-2017, 09:57 AM | #7 | |
Not Yet Wild
Join Date: Mar 2017
Posts: 25
|
Re: 96 gas club car
Quote:
I also have the fe290 Sent from my iPhone using Tapatalk |
|
03-10-2017, 02:06 PM | #8 |
Not Yet Wild
Join Date: Jul 2009
Location: ZolfoSprings. Fl
Posts: 32
|
Re: 96 gas club car
I tried it and it worked! Thanks Saladsack
|
03-10-2017, 05:22 PM | #9 |
Not Yet Wild
Join Date: Sep 2016
Location: Western mass
Posts: 9
|
Re: 96 gas club car
I have a 97 that had the same problem, took that **** carb apart 3 times. Hand over the intake seemed to get it going as well. I'm in cold weather so when I went out today to fire it, it didn't start. My choke wasn't working, I can only assume you have the big round black push button choke? I pulled out the air box and at the inlet there is a rubber gasket, it was pretty worn out, so I wrapped electrical tape around the cone/ tube that's attached to the choke button. It works like a charm now, no more pulling off the flex tube to manually block the carb..
|
03-10-2017, 06:01 PM | #10 |
Not Yet Wild
Join Date: Jul 2009
Location: ZolfoSprings. Fl
Posts: 32
|
Re: 96 gas club car
I will look at that tomorrow. Thanks
|