intermitantly no spark

[Denval]

gas Club Car 1994
My friend complains his cart will not start and has no spark , may play up twice a week. May not restart till the following day after manly attempts to
Every time I check it , it never faults
The RPM limited has been removed years ago ( was cutting out mid power range )
The oil level is ok but unsure if this model has an low oil level ignition cut out ?
Was intending to replace the coil and pick up I think they are one unit and check wiring to the coil at same time. Looks like the key switch will not switch off the ability to spark ?
Any advice ?

[Ozzysgolfcarts]

Originally Posted by Denval

gas Club Car 1994
My friend complains his cart will not start and has no spark , may play up twice a week. May not restart till the following day after manly attempts to
Every time I check it , it never faults
The RPM limited has been removed years ago ( was cutting out mid power range )
The oil level is ok but unsure if this model has an low oil level ignition cut out ?
Was intending to replace the coil and pick up I think they are one unit and check wiring to the coil at same time. Looks like the key switch will not switch off the ability to spark ?
Any advice ?

Replace coil and RPM limitor,

Sent from my VS880PP using Tapatalk

[Ozzysgolfcarts]

Originally Posted by Ozzysgolfcarts

Replace coil and RPM limitor,

Sent from my VS880PP using Tapatalk

Pickup on the coil itself is bad. Might be able to hear it apart and just clean everything and get it to work for a little bit. Can become full of rust.

Sent from my VS880PP using Tapatalk

[Denval]

I replaced the coil and for few seconds whilst retesting I had no spark
Worked out the small wire going to the coil is earthed to kill the spark
I followed wire back to the lower micro switch in the box with the throttle cam and solenoid etc. In removing a small drop of water came out the micro switch so I replaced it and appear to have solved my problem Thanks