|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
04-19-2018, 12:27 PM | #1 |
Not Yet Wild
Join Date: Jun 2017
Posts: 10
|
POP! burn smell, no move, resistor Hot!
2002 DS 48v
I have been having a problem with the cart spinning the wheels from the start. Very little speed control, jerking movements. It has never had reverse,bought it that way. Yesterday I was trying to drive it a little to see if the problem might resolve itself...it didn't. Suddenly I heard a loud pop!..smelled a hot burning smell, and the cart stopped moving. I turned off the key. A while later I found that the resistor on the solenoid was very very hot...ouch, with the key in the OFF position. I disconnected the batteries and hope you can give me some ideas. This Old Club Car DS 48v is my first cart. The batteries are fully charged and very strong. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-19-2018, 01:13 PM | #2 |
Gone Insane
Join Date: Oct 2016
Location: Richmond, VA
Posts: 14,215
|
Re: POP! burn smell, no move, resistor Hot!
GolfCartGuy told you a while back to check for a stuck brush in the motor. Did you do that?
|
04-19-2018, 02:42 PM | #3 |
Not Yet Wild
Join Date: Jun 2017
Posts: 10
|
Re: POP! burn smell, no move, resistor Hot!
Before i go to that major effort I, would like to know why a stuck brush would cause the issues I have described.????
|
07-07-2019, 02:01 PM | #4 |
Getting Wild
Join Date: Jun 2014
Location: In a van down by the river, between Iowa & Southern California
Posts: 87
|
Re: POP! burn smell, no move, resistor Hot!
I have a 2010 LSV that did the same thing. Pop then a burnt smell. It was hard to push back home! What is the most likely fix?
|
07-07-2019, 06:20 PM | #5 |
Gone Insane
Join Date: Oct 2016
Location: Richmond, VA
Posts: 14,215
|
Re: POP! burn smell, no move, resistor Hot!
|
07-07-2019, 06:39 PM | #6 |
Getting Wild
Join Date: Jun 2014
Location: In a van down by the river, between Iowa & Southern California
Posts: 87
|
Re: POP! burn smell, no move, resistor Hot!
Thanks. Not really concerned with his problems,but could use some help with mine, and it sounded similar.
|
07-07-2019, 09:02 PM | #7 | |
Not Yet Wild
Join Date: Apr 2019
Posts: 7
|
Re: POP! burn smell, no move, resistor Hot!
Quote:
If your resistor on the solenoid is hot/burned it means that you probably fried your controller. I had the same thing happen to mine. Replace the co troller and resistor and you should be good to go. Sent from my iPhone using Tapatalk |
|
07-07-2019, 10:33 PM | #8 | |
Gone Insane
Join Date: Oct 2016
Location: Richmond, VA
Posts: 14,215
|
Re: POP! burn smell, no move, resistor Hot!
Quote:
It could be bad but I would not replace it first thing. |
|
07-08-2019, 05:28 AM | #9 |
Gone Wild
Join Date: Jun 2018
Location: Richmond,Virginia
Posts: 550
|
Re: POP! burn smell, no move, resistor Hot!
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Hot resistor, burned pin 5, no reverse buzzer, cart won't move | Electric EZGO | |||
Belt Squeal, burn smell, then won't start | Gas Club Car | |||
Club Car (resistor cart) wont move | Electric Club Car | |||
Resistor coils smell Hot | Electric Club Car | |||
can I move my resistor coils closer | Electric EZGO |