|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
04-21-2019, 07:40 PM | #1 |
Getting Wild
Join Date: Jan 2016
Location: GA
Posts: 91
|
Picked up a 05 DS Gas, got some ?
So my parents had this 2005 DS sitting around they never use. It has an older lift on it and seems to be in decent physical condition.
They are offering it to me for $2000. Before I dive into it wanted to make sure it was worth it. It fires right up with out issue but just does not seem to have any power. Going up a hill it is barely faster than walking speed. I took it for a ride and at one point it cut out on me. It took a few tries to get it back going. Any idea on where to start? I pulled the plug and it was cover is dark black stuff and looks to be the wrong plug. It also needs a new drive belt, rear seat bottom and probably shocks as they seem completely worn out. Know that does it seem like it'd be worth 2K plus fixing it? |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-22-2019, 07:25 AM | #2 |
Getting Wild
Join Date: Oct 2008
Location: SE of the Indy 500
Posts: 92
|
Re: Picked up a 05 DS Gas, got some ?
IMHO it’s totally worth 2k and fixing up if that’s what you want to do. I would think it would be gone quickly at even 25-2600.
Give it a compression check if it’s good, tune it up, fresh fuel and put the belts on it. As far as power, the belt, Clutch, carb, or low compression could be the issue. |
04-22-2019, 07:36 AM | #3 |
Gone Wild
Join Date: Dec 2017
Location: Portsmouth, VA
Posts: 626
|
Re: Picked up a 05 DS Gas, got some ?
2k is not bad if it is in good condition, any picts ??
i picked up an 08 DS probably needs a tune up and new belts that is where i would start... maybe clutch rebuild/replace but can check that when you do the belts. mine ran ok, but i did a tune up and such and oh my what a difference runs smooth. still need new belts, but that is in the works my 1929 is priority one. hope to have that on the road this summer, then golf cart comes in for tear down and rebuild :) i'm a one man project, helps me stay focused !! be six years in June with the 1929 |
04-26-2019, 04:20 PM | #4 |
Getting Wild
Join Date: Jan 2016
Location: GA
Posts: 91
|
Re: Picked up a 05 DS Gas, got some ?
Installed a new (correct) spark plug
Checked the compression and its around 130, is that good? Drive belt actually looks new, seems loose though. It's a gates 6079, is that correct? Tried to check the valves, both valves were up and I could not get a .004 filer in the top. |
04-26-2019, 05:50 PM | #5 |
Nincompoop village idiot
Join Date: Apr 2018
Location: Michigan
Posts: 9,690
|
Re: Picked up a 05 DS Gas, got some ?
130 is low. But if you cant get a .004 in, they're too tight which can lower compression. also make sure you hold the carb wide open when testing or that will cause it to be low too.
|
04-26-2019, 06:55 PM | #6 | |
Getting Wild
Join Date: Jan 2016
Location: GA
Posts: 91
|
Re: Picked up a 05 DS Gas, got some ?
Quote:
Is there a guide with more detail on this so I can make sure I'm doing it correctly? |
|
04-27-2019, 01:18 PM | #7 |
Getting Wild
Join Date: Oct 2008
Location: SE of the Indy 500
Posts: 92
|
Re: Picked up a 05 DS Gas, got some ?
|
04-27-2019, 01:45 PM | #8 |
Getting Wild
Join Date: Jan 2016
Location: GA
Posts: 91
|
Re: Picked up a 05 DS Gas, got some ?
|
04-28-2019, 02:03 PM | #9 |
Getting Wild
Join Date: Jan 2016
Location: GA
Posts: 91
|
Re: Picked up a 05 DS Gas, got some ?
With the plug swap, valve adjustment and flushing all the old gas it now runs pretty good.
Still on the slow side but in think its because I am used to my RXV that's faster than most karts. |
04-28-2019, 02:32 PM | #10 |
Bonafide Nincompoop
Join Date: Dec 2015
Location: Charlottesburg Va
Posts: 8,987
|
Re: Picked up a 05 DS Gas, got some ?
You can use the zip tie trick and make a small adjustment to the governor arm to get a little more speed out of it. With those tires you should be able to get close to 20mph without hitting the rev limiter.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
just picked these up | Members Rides | |||
Here's what I picked up. | Electric Yamaha | |||
just picked up | Gas EZGO | |||
picked up another g1 | Gas Yamaha |