|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
09-26-2014, 07:49 AM | #11 |
Gone Wild
Join Date: Nov 2013
Posts: 706
|
Re: PDS throttle problem.
well i put the old its back in right after and it went back to acting up. waiting on the new its to get here so i can put her back together
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
09-29-2014, 08:39 AM | #12 |
Gone Wild
Join Date: Nov 2013
Posts: 706
|
Re: PDS throttle problem.
well now i have a new issue. i replaced the micro switch and the its and everything worked fri afternoon, i drove the cart again sat before i left my shop. got here this morning and the cart wont do anything, I put it in diagnostic mode and its giving me a 1-2 beep. throttle fault. It says solenoid clicks but will not run, my solenoid is not clicking.
|
09-29-2014, 08:39 AM | #13 |
Gone Wild
Join Date: Nov 2013
Posts: 706
|
Re: PDS throttle problem.
could it be the solenoid that is giving this issue
|
09-29-2014, 10:19 AM | #14 |
Gone Wild
Join Date: Jan 2014
Location: South Georgia
Posts: 1,120
|
Re: PDS throttle problem.
Never try to guess what might be the trouble with a PDS. Get your voltmeter out and get ready to make some measurements. Someone will post a link to a PDS wiring diagram and we have a bunch eager and waiting to help you troubleshoot.
|
09-29-2014, 11:32 AM | #15 |
Gone Wild
Join Date: Nov 2013
Posts: 706
|
Re: PDS throttle problem.
i went outside to look at it earlier and wiggles the throttle wire and it worked. drove it a little with no issue then parked it inside my shop and plugged the charger in and now it wont move. gonna put another throttle harness in to see if that works. i tried to wiggle the wires some more but couldnt get it running again
|
09-29-2014, 12:20 PM | #16 | |
Gone Wild
Join Date: Jan 2014
Location: South Georgia
Posts: 1,120
|
Re: PDS throttle problem.
Quote:
|
|
09-29-2014, 12:31 PM | #17 |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: PDS throttle problem.
A stock PDS drive system is Fly-by-Wire system and the controller does everything and it sounds like you have more than one problem.
If the pack voltage is above about 37, it is sufficient for troubleshooting. Getting the solenoid to click is the first objective. To do that, there must be pack voltage on all the wires highlighted in red on attached schematic. |
09-29-2014, 12:50 PM | #18 |
Gone Wild
Join Date: Nov 2013
Posts: 706
|
Re: PDS throttle problem.
I unplugged it before i tried to drive it, lol. I have a donor PDS here so i will just start moving stuff over till i find the problem. Starting with solenoid then im gonna replace wire harness
|
09-29-2014, 01:10 PM | #19 |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: PDS throttle problem.
Be sure to flip the RUN/Tow switch to Tow while disconnecting and reconnecting stuff.
|
09-29-2014, 02:49 PM | #20 |
Gone Wild
Join Date: Nov 2013
Posts: 706
|
Re: PDS throttle problem.
ok so i put the new solenoid in and nothing, changed out the throttle harness and nothing, changed out the controller and it came alive a little in foward, let off throttle and put it in reverse and nothing, now i get nothing at all.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
throttle problem? | Electric EZGO | |||
Throttle problem? | Electric Club Car | |||
throttle problem | Electric EZGO | |||
throttle problem,new controller,throttle works backwards | Electric EZGO | |||
Throttle Problem | Gas Club Car |