|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
02-26-2012, 02:32 PM | #11 |
Getting Wild
Join Date: Dec 2011
Posts: 99
|
Re: 88 ezgo 2cycle engine problems
dave will probally buy the pump and new gas cap if i can get the cart running again hotrod
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
02-27-2012, 08:37 PM | #12 |
I Refuse To Get Stuck!!!
Join Date: Jun 2010
Location: Hilton,NY
Posts: 5,427
|
Re: 88 ezgo 2cycle engine problems
If it cranks alot,then finally fires,but sputters briefly,it sounds like the pump is draining-back.You can get a rebuild-kit for the pump for around $15.Most Mower-Shops should be able to get it,If not,check dirt-bike/quad dealers or shops.Its' a very common pump.Also replace the fuel-lines from tank to pump,pump to carb.and a new filter.This guarantees no restrictions or air-leaks(suction)Use the good pliable fuel-line like they use on sleds,its' about $6/ft and worth it.It doesn't require clamps and stays soft,but seals like its' welded on!Also,check the pick-up in the tank,mine had a problem that it was cracked,and when the fuel got down to a certain level it would run awful,added some fuel and it was fine.Hope this helps.
|
02-28-2012, 10:25 AM | #13 |
Getting Wild
Join Date: Dec 2011
Posts: 99
|
Re: 88 ezgo 2cycle engine problems
got the cart running for about 3 min. then it rev up and the clutch started slipping and it died. pulled back to garage and let it set for 30 min. started right up back out of garage and pu in forward and it sputtered and died. pushed back in garage and let it set. do not know where to start looking for the problem. hot rod
|
02-28-2012, 08:07 PM | #14 |
I Refuse To Get Stuck!!!
Join Date: Jun 2010
Location: Hilton,NY
Posts: 5,427
|
Re: 88 ezgo 2cycle engine problems
When you say the clutch slipping,Do you mean the starter-belt was slipping on it,and the engine won't turn over?If so,either adjust the starter-belt tension,or replace the belt.If its' sitting down inside the starter pulley,or the pulley on the clutch,its' worn and won't grab properly.Hope this helps.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
EzGo driven the same? 2cycle vs 4 cycle | Gas EZGO | |||
88 ezgo 2cycle-oil change? | Gas EZGO | |||
86 2cycle ezgo!!!!! | Gas EZGO | |||
need ezgo 2cycle clutch | Electric EZGO | |||
ezgo st 2+2 engine problems | Gas EZGO |