10-23-2012, 03:02 PM | #1 |
Not Yet Wild
Join Date: Oct 2010
Posts: 34
|
05 wierd go-nogo
I have an 05 DS cc that the obc was bad... I decided to try and replace the obc with a micro processor on the charger..
charging cycle worked ok - - car will run about 5 foot then shut down.. diconnect main neg.. and then start over agian and car will run about 5 feet. replaced soleniod thinking that was bad and I get the same results. any ideas as to what I need to look at???? |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
10-23-2012, 03:38 PM | #2 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,419
|
Re: 05 wierd go-nogo
One of the obc functions is to provide the negative side of the activation circuit for the solenoid...
When the cart won't go, does the solenoid click? |
10-23-2012, 09:26 PM | #3 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 05 wierd go-nogo
You say you replaced the OBC with a microprocessor on the charger.... What did you do with the OBC? How did you eliminate it from the car? You can't just remove it and throw it out. Certain wires have to be bypassed certain ways. Is this a series car or an IQ car?
|
10-24-2012, 09:43 AM | #4 |
Not Yet Wild
Join Date: Oct 2010
Posts: 34
|
Re: 05 wierd go-nogo
thie is an IQ and the obc was bad and removed. followed the instructions which cut out the wires on the obc. yes I get soleniod click but it will drop out and thought we had a bad soleniod but a new one does the same thing.
|
10-24-2012, 01:39 PM | #5 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 05 wierd go-nogo
And what did the instructions tell you to do as far as OBC bypass is concerned?
|
10-24-2012, 04:53 PM | #6 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: 05 wierd go-nogo
|
10-25-2012, 02:21 PM | #7 |
Not Yet Wild
Join Date: Oct 2010
Posts: 34
|
Re: 05 wierd go-nogo
obc is in place. follow the wiring connections and everything looks correct..
I have no fault codes on controller.. car runs about 5 feet and stops.. reset everything and does the same thing.. |
10-25-2012, 04:13 PM | #8 |
Not Yet Wild
Join Date: Oct 2010
Posts: 34
|
Re: 05 wierd go-nogo
instructions were to cut black wire on charger rec reroute wire to battery main neg.
for IQ cars - cut light blue wire at pin 5 then attach wire to cut in blue wire and rout to pos side of soleniod. tape up end of blue wire going into 16 pin connector car does charge correctly. |
10-25-2012, 04:22 PM | #9 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 05 wierd go-nogo
OK you did it properly. What is your battery voltage? A weak car can drop voltage so low upon acceleration that it will stall.
|
10-26-2012, 09:25 AM | #10 |
Not Yet Wild
Join Date: Oct 2010
Posts: 34
|
Re: 05 wierd go-nogo
I have 49 volts for reference and I do not see a drop when car stops.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
wierd electrical issue g1 | Gas Yamaha | |||
Robins running wierd - Video link | Gas EZGO | |||
genertor motor won't turn off - wierd | Gas Club Car | |||
Wierd noise | Gas Yamaha | |||
cable wired wierd | Electric EZGO |