|
|
|||||||
| Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
  |
|
|
Thread Tools | Display Modes |
10-11-2009, 04:49 PM
|
#1 |
|
Not Yet Wild
Join Date: Oct 2009
Posts: 8
|
batteries/ its / or controller
Wheels will turn when jacked up. The cart trys to go when on the ground but will not. Voltage is 37.5 when idle. drops to 33.5 when on the ground and fails to move with a jerking motion. Diagnostic test posted by Sticky indicates that all is good but the ITS. ITS 14.5 volts when disconnected. ITS box is clean and micro works ok and adjustment appears to be fine.
Any ideas. Thanks |
|
|
 Today
|
|
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
|
10-11-2009, 04:53 PM
|
#2 |
|
Gone Wild
 Join Date: Mar 2008
Location: Rockwall, Texas (Dallas / Ft. Worth)
Posts: 7,077
|
Re: batteries/ its / or controller
Batteries are not good - dropping to 33 volts means they are quite weak.
|
|
|
|
|
|
|
|
10-11-2009, 05:26 PM
|
#3 |
|
Not Yet Wild
Join Date: Oct 2009
Posts: 8
|
Re: batteries/ its / or controller
Thanks
Ive been using NAPA batteries Are Trojans better  |
|
|
|
|
10-11-2009, 10:26 PM
|
#4 |
|
Not Yet Wild
Join Date: Oct 2009
Location: Virginia Beach, VA
Posts: 62
|
Re: batteries/ its / or controller
anythig is better than dead batteries. ;)
|
|
|
|
|
10-11-2009, 10:27 PM
|
#5 | |
|
Not Yet Wild
Join Date: Oct 2009
Location: Virginia Beach, VA
Posts: 62
|
Re: batteries/ its / or controller
 Quote:
|
|
|
|
|
|
10-11-2009, 10:30 PM
|
#6 | |
|
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,401
|
Re: batteries/ its / or controller
Quote:
|
|
|
|
|
10-12-2009, 05:51 AM
|
#7 |
|
Not Yet Wild
Join Date: Mar 2009
Location: wizzardcarts57@gmail.com
Posts: 46
|
Re: batteries/ its / or controller
Is Your Cart Series Take A Good Look At Fwd Rev Switch Check Discolaration Of Copper Contacks Most Likely This Is Were Your Problem Is -its Inductive Sensor,s Never Go Bad Unless Sumerged In Water ,might Want To Change Solonoid While Your In There
|
|
|
|
|
10-12-2009, 06:10 AM
|
#8 |
|
nimda
Join Date: Jun 2007
Posts: 13,022
|
Re: batteries/ its / or controller
ITS should range test from around .4-.5 to 1.4 to 1.5. Anything higher than that and the ITS is bad.
|
|
|
|
|
10-12-2009, 06:11 AM
|
#9 | |
|
Not Yet Wild
Join Date: Oct 2009
Location: Virginia Beach, VA
Posts: 62
|
Re: batteries/ its / or controller
Quote:
 |
|
|
|
|
|
10-12-2009, 11:13 AM
|
#10 |
|
Not Yet Wild
Join Date: Oct 2009
Posts: 8
|
Re: batteries/ its / or controller
The cart is a 97 DCS. Micro's check ok.
|
|
|
|
|
|
||||||
| Thread Tools | |
| Display Modes | |
|
|
Similar Threads
|
||||
| Thread | Forum | |||
| Changed batteries/batteries won't charge | Electric Club Car | |||
| Electric Ezgo Battery Charge (Batteries or controller?) | Electric EZGO | |||
| Help please: Controller problems after replacing batteries in a 36v melex | Electric golf carts | |||
| Did lift kit cause controller to die? What are controller options? 95 EZGO 25864G05 | Electric EZGO | |||
Linear Mode
